Professional Documents
Culture Documents
Position 2
① Day and Date OK and NG are on the Set all hands straight up to
straight, too. (Chart 3)
left side of the dial. 12 o'clock.
Position 1
Pull the crown to the Position 1.
1.
Second hand Button B 6.When all 3 hands reach to 12 o clock position,
Please note the crown may be already in ④ Time zone confirmation
please see date changes to today.
*Please use something thin to press button B. Please be
Position 1 (not pushed fully).
(In the example of 25th Tuesday, the watch
careful not to hurt yourself or scratch the case. 1.At time of factory shipment, time zone is set
Turn the crown to the front/back to set
2. will temporary show 25th Monday.)
to LON, LAX or TYO. (It depends on the
date/day. If the date is not changed, please move
marketplace.) Chart
Push the crown and proceed to step ②.
3. 2
minute and hour hands forward and set them
■Display
2.Press button B and see up straight again.
where red hand shows
Time Zone Calendar 7.Push the crown to the normal position.
Day of the week (Chart 2).
Display
Day (English/Spanish) 8. The watch adjusts itself. Please do not press
Sunday SUN / DOM 3.Please see [4 Time zone] City codes are on
outer side of dial any buttons until it s finished.
Monday MON / LUN to change time zone.
LB
When you change time zone, you can check the [ Automatic reception ] This watch works with solar rechargeable battery. When the battery is exhausted, this watch will be
time of another city. You need to expose the dial to light source to in power saving mode and stop.
This watch automatically attempt reception at 3
*Radio transmission station will be automatically charge battery. To recover from power saving mode, expose the
and 4 am.
selected according to the time zone. On cloudy days or in winter, it may take longer to watch into strong light source.
Put the watch at good place to receive radio wave
Please see [9 Radio wave stations]. recharge.
(by the window, for example.) After recovery, please recharge battery fully.
Estimated charging time is shown on the table
[How to confirm time zone] When reception succeeded, it adjusts itself Calibration may be needed after recovery. Please
below.
automatically. see [3 Zero calibration].
1.Press button B. Red hand rotates and shows The watch tends to be lack of power under
time zone. situation such as:
*Please press button B while the crown is in [ Manual reception ]
- The watch is hiding under your clothing.
8 Water p r oof
normal position. - You keep to use/store the watch in the dark
You can start reception anytime you want.
place. - This watch has 10 ATM (10 bars, 100 meters)
[ Time zone setup ] 1.Put the watch at good place to receive radio
water resistant.
wave. [ How to check battery remaining ] - Water resistant performance will deteriorate
1.Press and hold button B. Red hand rotates
over time. To maintain the performance, the
and shows UTC . 2.Press and hold button A. 1.Press button A. Red hand will rotate and
Chart watch needs professional inspection once in 2-3
*If it shows somewhere else, it needs Red hand rotates and 4 show result of reception at first.
years.
calibration. Please see [3 Zero calibration]. shows transmission
2.Please wait and see for 5 seconds. Red hand - Water resistant performance is not necessarily
station.
LB
2.Press button A to select time zone. City code will rotate again and show battery remaining. corresponding to the water pressure.
*If the transmission
table is in [9 Radio wave stations]. (Chart 5) - Please do not leave the crown pulled. It may be
station is not where you
Name of stations are cause of water penetration.
want, please keep holding Chart
HB : Fully charged.
shown at left side of dial. - Please do not move the crown or push any
3.Press button B to determine time zone. 5
button A. NB : Enough charged.
buttons under water.
Please see [9 Radio wave
LB
10,000 10-20
Direct sunlight 6-8 hours
-100,000 minutes
*This shows the last attempt was succeeded
or failed. It doesn t show current environ- Sunlight
(cloudy)
80
ment is good for reception or not. 3,000
minutes
60 hours
30W fluorescent light
within 20cm (7.9")
■Red hand doesn t move when I press To recover from power saving mode, expose
J60 (60kHz) the watch to enough light source.
1,000km buttons.
The battery may be low. Please recharge. Please also see [7 Power saving mode].
1,000km
Please see [6 Solar battery] for more informa-
WWVB
Time Zone
tion.
(60kHz)