Professional Documents
Culture Documents
1. While designing for biaxial columns, if the analysis moments are less than minimum design
moments (based on minimum eccentricity- Mmin = Pu (15+.03h)) in both the directions
simultaneously,
then the final design will be based on the worst of the following two cases:
a. M2 = M2min
M3 = M3
b. M2 = M2
M3 = M3 min
The design should not be based on M2= M2min and M3= M3 min. It is sufficient to ensure that
eccentricity exceeds the minimum about one axis at a time.
It should be further noted that in case both the above cases results in rebar % less than 1 %,
ETABS will report the results for
M2 = M2
M3 = M3 min
2. In case when the analysis moment in one direction exceeds the minimum design moment, the
design should be based on the following case: