Professional Documents
Culture Documents
GRS77 H EnvironmentalQualificationForm
GRS77 H EnvironmentalQualificationForm
Nomenclature:
GRS77 Attitude and Heading Reference System
Type/Model/Part Number:
GRS77 GPN 010-00295-( ) (Includes 011-00868-( ))
TSO Numbers:
TSO – C3d
TSO – C4c Turn Error Category A
TSO – C6d
Manufacturer:
Garmin Ltd. or its subsidiaries
Address:
1200 East 151st Street
Olathe, Kansas 66062
U.S.A.
Date Tested:
September 2003 – February 2004 (original tests); November 2009 – February 2010 (most recent additional testing).
DO-160D
RTCA D O - 1 6 0 D Conditions Section and Description of Conducted Tests
Date of Issue
Temperature and Altitude 4.0 Equipment tested to Categories A 2 F 2
Ground Survival Low/Operating Low 4.5.1
Ground Survival High/Short-Time Operating High 4.5.2
Operating Temperature High 4.5.3
In-Flight Loss of Cooling 4.5.4 Not Applicable – Cooling Not Required
Altitude 4.6.1
Decompression 4.6.2
Overpressure 4.6.3
(Issued 07/29/97)
Temperature Variation 5.0 Equipment tested to Category B
(Issued 07/29/97)
Humidity 6.0 Equipment tested to Category B
(Issued 07/29/97)
Sustained Crash Safety 7.3.2 Equipment tested to Aircraft Type 5, Test Type R
(Issued 07/29/97)
Vibration 8.0 GRS 77 (011-00868-00 and 011-00868-10): Equipment
(Change No. 1 tested to Category S2, Test Curve B 2 , and Category
Issued 12/14/2000)
S, Test Curve M. (See Note 1.)
1. Vibration Test Curve M was increased as follows: 0.1 inches pk-pk double amplitude from 15Hz to 17Hz and 1.5g pk from 17Hz to
55Hz.
2. The GRS77 meets Category Z except for the one second interrupt in Section 16.5.2.3. This requirement corresponds to Test Condition
Numbers 8 and 15 in Table 16-1A referenced by Sections 16.5.2.3 and 16.5.1.4.b. For Momentary Power Interruption, the unit does not
reset for Category A( ) and B interrupts (200 ms max), but does reset for Category Z interrupts (1 second max).
3. For the Pin Injection tests, all connector pins were tested to Category A3 (Level 3, Waveforms 3 and 4) except Configuration Module and
unused (spare) pins. In addition, all power input pins and GMU44 interconnect pins were tested to Category A4 (Level 4, Waveforms 3
and 4). Note that both power input pins must be connected to the same aircraft power bus to meet Level 4, Waveform 4 of Category A4.
4. Qualification to additional levels and configurations are shown in Garmin Report 005-00329-06 Supplemental Qualification Summary.