Professional Documents
Culture Documents
A E R 0 S P A C F.
MAINTENANCEMANUAL
GARRETTTPE331-10 (REPORT NO. 72-00-28)
TEMPORARYREVISION, o
To holders of Turboprop A i r c r a f t Engine ~laintenance Manual Report No. 72-00-28,
Revision 9, dated July 19, 1994. Insert facing page 237, 72-50-07.
Use the following steps 2.F.(8) and (9) in l i e u of existing steps 2.F.(8) and
(9).
2. F. (8) (Pre SB 72-0903) Visually inspect turbine wheel rivets as follows.
(a) Inspect turbine wheel for evidence of loose r i v e t s . I f loose
r i v e t s are suspected, check f o r movement using l i g h t force
(approximately 5 pounds). No movement allowed. Refer to Ap-
proved Repairs.
(b) Inspect pin f l a r e on both ends. Pins shall be flared 360 de-
grees around. Entire circumference of f l a r e at each end shall
extend into or beyond corner break on wheel surface.
(d) Inspect turbine wheel for missing pins. Discard turbine wheel
i f one or more pins are missing.
(e) Second stage turbine rotor which have loose pins or unaccepta-
ble pin flares may be sent to the following repair f a c i l i t y .
AlliedSignal Engines
D i s t r i b u t i o n Center
1944 East Sky Harbor Circle
Phoenix, AZ 85034
72-50-07
(FAA APPROVED)
Page i of 2
Copyright 1994 AlliedSignal Inc. Nov 22/94
~lliedSignal
A F. R o s P A C. E
MAINTENANCEMANUAL
GARRETTTPE331-10 (REPORT NO. 72-00-28)
WHEElSURFACE'.-......~~
.
(Post SB 72-0903)
Second Stage Turbine Rotor Pin Inspection
Figure 210B 72-50-07
(FAA APPROVED)
Page 2 of 2
Nov 22/94