This document describes an electronics laboratory activity on capacitative rectification. The objectives are to learn filtering of rectified signals, ripple voltage and ripple factor, and capacitive filtering. The procedure involves building and simulating half-wave and full-wave rectifier circuits using diodes, resistors, capacitors, and AC voltage sources to observe the input and filtered output waveforms.
This document describes an electronics laboratory activity on capacitative rectification. The objectives are to learn filtering of rectified signals, ripple voltage and ripple factor, and capacitive filtering. The procedure involves building and simulating half-wave and full-wave rectifier circuits using diodes, resistors, capacitors, and AC voltage sources to observe the input and filtered output waveforms.
This document describes an electronics laboratory activity on capacitative rectification. The objectives are to learn filtering of rectified signals, ripple voltage and ripple factor, and capacitive filtering. The procedure involves building and simulating half-wave and full-wave rectifier circuits using diodes, resistors, capacitors, and AC voltage sources to observe the input and filtered output waveforms.
Name: Kobe Wilson B. Mercado ID No.: 2021300254 Date Submitted: Feb. 26, 2021
Online Activity 4
Capacitative Rectification
Objectives
At the end of the activity, the student would be able to:
1. Learn filtering of rectified signal
2. Learn ripple voltage and ripple factor 3. Learn capacitive filtering
Procedure
Capacitative Rectification for Half Wave Rectifier
1. Take a diode, and Load resistor of 1 kΩ and capacitor of 102 μF.
2. Connect to AC Voltage Source of 50 Hz, 2 V 3. Click on 'ON' button to make the circuit on. 4. Click on 'Sine Wave' button to observe the input waveform. 5. Click on 'Run Simulation' button to observe the filtered waveform. 6. Observe the corresponding waveform. 7. Channel 1 shows the input wave, Channel 2 shows the output wave and Dual shows both the input and output wave. Capacitative Rectification for Full Wave Rectifier
1. Take 4 diodes, Load resistor of 1KOhms and capacitor of 102μF.
2. Connect to AC Voltage Source of 50 Hz, 12 V. 3. Click on 'ON' button to make the circuit on. 4. Click on 'Sine Wave' button to observe the input waveform. 5. Click on 'Run Simulation' button to observe the filtered waveform. 6. Vary the amplitude using the controllers. 7. Observe the corresponding waveform. 8. Channel 1 shows the input wave, Channel 2 shows the output wave and Dual shows both the input and output wave.