Professional Documents
Culture Documents
CYP DVT2 Dye & Pry
CYP DVT2 Dye & Pry
No: NBB-221205-V00
1
Result Of Test
1 – Introduction:
One piece of PCBA were received from EMS2 for Dye & Pry analysis. The specimens
to be tested were specified as follows.
2 - Sample Information:
Sample No
SN Dye & Pry
U401,U1701,WU601,WU602,WU101,WU301,WU210,W
ABZ24700529
#1 U501,U1601,U1501,U1101,WU751,WPA401,Wu701,WU
1002,WU1001,WPA202,WPA201
3 - Test Procedure :
Clean any flux residue from around the BGA solder bumps using an approved Flux
Remover. Immerse the sectioned sample in the dye then place it into vacuum chamber
to aid in dye penetration. Dry the sample in an oven by baking at 100℃ for up to 3
hours. The component is removed by mechanical method. Use microscope to examine
the board and part, take photos of dyed regions.
SUB TOP
U401 U1701
SUB TOP
WU601 WU602
WU101
WU501
WU210
WU301
Result Of Test
5 – Test location: SUB BOT
SUB BOT
U1601
U1101
U1501
SUB BOT
Wu701
WU751
WPA401
WPA202
WU1002
WU1001
WPA201
Result Of Test
6. Test result
Figure 1
U401-Side 1
BGA Side
PCB Side
Result Of Test
6. Test result
Figure 26
Wu701
Page 33 of 34
Result Of Test
End of Report
Page 34 of 34