1. The document outlines the initialization, start up, taxi, take off, cruise, approach, and landing procedures for an aircraft.
2. It provides detailed steps for cockpit initialization, engine start, navigation preparation, taxi, after takeoff and cruising, approach, and landing.
3. The procedures include setting switches, levers, radios, fuel pumps, generators, bleeds, and other systems through each phase of flight.
1. The document outlines the initialization, start up, taxi, take off, cruise, approach, and landing procedures for an aircraft.
2. It provides detailed steps for cockpit initialization, engine start, navigation preparation, taxi, after takeoff and cruising, approach, and landing.
3. The procedures include setting switches, levers, radios, fuel pumps, generators, bleeds, and other systems through each phase of flight.
1. The document outlines the initialization, start up, taxi, take off, cruise, approach, and landing procedures for an aircraft.
2. It provides detailed steps for cockpit initialization, engine start, navigation preparation, taxi, after takeoff and cruising, approach, and landing.
3. The procedures include setting switches, levers, radios, fuel pumps, generators, bleeds, and other systems through each phase of flight.
COCKPIT INITIALIZATION ENGINE START BEFORE TAKE OFF
1. SWTCH & LVR Init 1. Set BEACON to ON 1. Set PARK BRAKE to ON
2. PWR Init 2. Set HYD to AUTO 2. Check VR a. Set BAT to ON 3. Set GEN to ON 3. Set Al meter b. Set STANDBY POWER to AUTO 4. Set BUS TIE to AUTO 4. Set F/D 3. NAV Init 5. FUEL Init 5. Set LNAV/HDG a. Set IRS to NAV a. Set FUEL MNTR 6. Set VS/FLC b. Set NAV LGHT to ON b. Set FUEL PUMP to ON 7. Set SPEED 4. Set SIGNS c. Set FUEL XFEED 8. Set ELEVATOR TRIM 5. APU 6. ENG Init 9. Set SPEEDBRAKE a. Set FUEL PUMP to OFF a. Set ENG PAGE on MNTR 10. Set FLAPS b. Set APU BLEED to ON b. Set ENG BLEED# to ON 11. Set TRANSPONDER c. Set APU to START c. Set ENG START# 12. Set LAND LT to ON d. Set APU GEN to ON d. Wait N2>20% 13. Set AUTOBRAKE to RTO e. Check ELEC e. Set ENG RUN# 14. Set DISPLAY f. Wait ENG# RUNNING 15. Set PARKING BRAKE to OFF g. Repeat ENG START# Retract NAVIGATION PREPARATION h. Set FUEL MNTR i. Check FUEL FLOW Stable AFTER TAKE OFF & CRUISING 1. FMS j. Check EICAS Stable a. Set POS INIT 7. Set APU to OFF 1. Set GEAR & FLAP b. Set ROUTE 8. Set WINDOW HEAT 2. Set A/PILOT & A/THROTTLE c. Set DEP 9. Set ANTI-ICE 3. Set LAND LT to OFF d. Set PERF INIT 4. > FL100 set SIGNS e. Set THRUST LIMIT f. Set TAKEOFF TAXI g. Set LEGS APPROACH & LANDING 2. FCGP 1. Set TAXI & RWY LGHT to ON a. Set ALTITUDE 2. Set PARK BRAKE to OFF 1. Approach b. Set HDG a. Set ARR b. Set ARRIVAL PERF c. < FL100 set SIGNS d. Set ILS FREQ e. Set HDG/CRS f. Set DH/MDA g. Set AUTOBRAKE 2. Landing a. Set FLAPS & GEAR b. Set LAND LT to ON