Professional Documents
Culture Documents
1) The input power to a device is 5000 W at 400 V. The output power of the device is 750 W, and the 1)
output impedance is 25 Ω. Calculate the power gain in decibles.
A) 16.478 dB B) 8.239 dB C) -8.239 dB D) -16.478 dB
2) The input power to a device is 5000 W at 400 V. The output power of the device is 750 W, and the 2)
output impedance is 25 Ω. Calculate the voltage gain in decibles.
A) 4.6556 dB B) -9.311 dB C) 9.311 dB D) -4.6556 dB
3) To fix the frequency boundaries of relatively high gain, 0.7 Amid was chosen to be at the cutoff 3)
levels. The corresponding frequencies, f1 and f2 , are generally called ________.
A) cutoff frequencies B) half-power frequencies
C) corner frequencies D) All of the above
4) What is the proper equation for calculating the low frequency break point due to the capacitor CS 4)
for this BJT amplifier?
1 1
A) fLs = B) fLs =
2π RS + R1 R2 CS 2π R S + R1 + R2 CS
1 1
C) fLs = D) fLs =
2π RS + Ri CS 2π R S Ri CS
5) Ri is calcualted as 5)
A) RS +R1 R2 βre B) RS +R1 R2 βRE
C) RS +R1 R2 β(RE + 1) D) None of the above
1
6) What is the proper equation for calculating the low frequency break point due to the capacitor CC 6)
for this BJT amplifier.
1 1
A) fLC = B) fLC = =
2π(ro + RL)CC 2π Ro + RL CC
1 1
C) fLC = D) fLC =
2πRCCC 2π RC RL CC
7) If several identical stages of amplifiers, each having the exact same upper and lower cutoff 7)
frequencies, are connected in cascade, then the bandwidth of the resulting amplifier will ________.
A) increase
B) remain unchanged
C) be equal to the sum of all the individual bandwidths
D) decrease
8) When using square-wave testing on two different amplifiers, you see the waveforms shown here. 8)
What comments can you make about the frequency response of the two amplifiers?
A) Amplifier A has poor low frequency response, while amplifier B has poor high frequency
response.
B) Amplifier A has poor low frequency response, while amplifier B has poor low frequency
response.
C) Amplifier A has poor high frequency response, while amplifier B has poor low frequency
response.
D) Amplifier A has poor high frequency response, while amplifier B has poor high frequency
response.
2
10) The base-10 logarithm of 1780.331 ________. 10)
A) 33.5 B) 3.2505
C) 0.335 D) None of the above
14) The term semi-log refers to a graphical scale that has ________. 14)
A) a linear vertical axis and a log horizontal axis
B) a log-log structure
C) a linear axis and a log axis
D) All of the above
15) The common log of the ratio of two power levels is called a ________. 15)
A) big bel B) bel
C) decibel D) None of the above
17) An amplifier has a midband power gain of 24,500. What is the value of the power gain in dB for 17)
the circuit?
A) 43.9 dB B) 87.78 dB
C) 4.39 dB D) None of the above
18) An amplifier has values of Pin = 20 mW and Pout = 60 W. What is the value of the power gain in 18)
dB for the circuit?
A) 69.5 dB B) 34.8 dB
C) 3000 dB D) None of the above
19) An amplifier normally has a power gain of 12,000. If the power gain of the circuit drops by 3 dB, 19)
the value of the new power-gain will be approximately ________.
A) 9,000 B) zero C) 6,000 D) 4,000
3
21) Which of the following is an advantage of using dB representations of gain values? 21)
A) Using db values, we can represent large gain values with relatively small numbers.
B) Positive and negative dB values represent gain and loss values that are reciprocals of each
other.
C) In multistage amplifiers, gain calculations are simplified by the use of dB values.
D) All of the above
22) An amplifier has an output power of 500 W. What is the value of the power gain in dB for the 22)
circuit?
A) 56.99 dB
B) 53.98 dB
C) 26.99 dB
D) Cannot be determined from the information given
23) An amplifier delivers 500 W to a 600 Ω load. What is the gain in dBm? 23)
A) 53.98 dBm
B) 26.99 dBm
C) 56.99 dBm
D) Cannot be determined from the information given
24) An amplifier has values of power gain = 49 dB and voltage gain = 30 dB. The operating frequency 24)
of the circuit is increased until the power gain drops to 42 dB. What is the dB voltage gain at this
frequency?
A) 25.7 dB
B) 42 dB
C) 23 dB
D) Cannot be determined from the information given
27) The roll-off rate for a BJT amplifier is approximately ________. 27)
A) 6 dB per decade B) 20 dB per octave
C) 6 dB per octave D) None of the above
4
30) The input value of f1 for a FET amplifier normally is ________ the input value of f1 for a 30)
comparable BJT amplifier.
A) much lower than B) less than or equal to
C) similar to D) greater than
34) Two identical amplifiers are cascaded. The overall bandwidth of the multistage amplifier is 34)
________ the bandwidth of each individual stage.
A) greater than B) equal to
C) less than or equal to D) less than
36) Which one of the following equations provides the Miller effect input capacitance for a BJT 36)
amplifier?
1 1 1
A) 1 - Av Cf B) C) 1 - C D)
2πR Th iCi Av f 1 - Av Cf
37) Which one of the following equations provides the Miller effect output capacitance for a BJT 37)
amplifier?
1 1 1
A) B) C) 1 - Av Cf D) 1 - C
1 - Av Cf 2πR Th iCi Av f
38) Which network tends to determine the upper cutoff frequency of a FET amplifier? 38)
A) the output B) neither C) both D) the input
5
41) In order to double the sound level perceived by a human ear, the power of the acoustical source 41)
must be increased by a factor of ________.
A) 2 B) 10 C) 3 dB D) 4
42) Parasitic capacitance values primarily affect the ________ frequency range while coupling 42)
capacitors affect the ________ range.
A) low, low B) low, high C) hjigh, high D) high. low
44) An amplifier with a gain of 40 has a bandwidth of 150 kHz. The unity gain frequency of this 44)
amplifer is ________.
A) 6 MHz B) 212 kHz C) 190 kHz D) 150 kHz
45) An amplifier has a GBP value of 150 MHz at 600 kHz. At 200 kHz its gain will be ________. 45)
A) 200 B) 3 C) 750 D) 150
6
Answer Key
Testname: UNTITLED113
1) C
2) B
3) D
4) C
5) A
6) B
7) D
8) C
9) B
10) B
11) A
12) B
13) D
14) C
15) B
16) A
17) A
18) B
19) C
20) B
21) D
22) D
23) C
24) C
25) C
26) C
27) C
28) B
29) C
30) C
31) A
32) D
33) A
34) D
35) D
36) A
37) D
38) D
39) B
40) C
41) B
42) D
43) A
44) A
45) C