Professional Documents
Culture Documents
SECTION 02840 Concrete Wheel Bumpers
SECTION 02840 Concrete Wheel Bumpers
NTS: This specification section requires careful review by the specifier. The specifier is
required to modify the section according to the requirements of the project. Brackets
indicate items to be checked, completed, edited, selected, or filled in. NTS notations and
brackets should be removed in the final printing.
PART 1 GENERAL
1.1 SUMMARY
A. Furnish and install concrete wheel bumpers (wheel stops) as indicated on the drawings
and specified.
B. Product Data: Submit information describing the materials used in the manufacture of
the wheel bumpers.
1.2 SUBMITTALS
1. LEED Credit MR Cost Data: Provide special materials cost data breakdown data
for the following materials:
2. LEED Credit MRc5.1: Provide manufacturer name and location data for the
following materials:
3. LEED Credit MRc5.2: Provide data from the manufacturer indicating the
sources, including source name and locations, of raw materials used to fabricate
the following materials. If different raw material sources are used the
manufacturer shall provide a breakdown based on percentage of weight of
materials used in the product for each different raw materials source used:
PART 2 PRODUCTS
2.1 MATERIALS
1. Minimum compressive strength: 4,000 pounds per square inch (psi) minimum at
28 days.
C. Anchor stakes for driving into the ground shall be No. 4 reinforcing bars or steel pipe
conforming to ASTM A53.
D. Adhesive for Securing of Concrete Wheel Bumpers: An epoxy two-component type, long
curing, manufactured by Edeco, Furance, Andrew Brown, Adhesive Engineering
Company, or equal.
PART 3 EXECUTION
A. Secure bumpers in place with steel stakes, two per bumper, driven to at least 1/4-inch
below top surface of the bumper, through the pavement and not less than 12 inches into
the subgrade.
END OF SECTION