Professional Documents
Culture Documents
PHYSICS
1 A 2 C 3 B 4 A 5 D 6 B
7 AD 8 ACD 9 AD 10 AD 11 AC 12 AC
13 3 14 2 15 2 16 5 17 2 18 8
CHEMISTRY
19 D 20 B 21 B 22 C 23 C
24 A 25 AB 26 ABC 27 D 28 BC
MATHEMATICS
37 B 38 B 39 C 40 A 41 C 42 B
49 2 50 5 51 4 52 1 53 4 54 2
SOLUTIONS
1. (A)
From l m1r12 m2 r22 and m1r12 m2 r22 , we N 2 W 10 kg 10 m/s 2 100 N
get 200
The frictional force is, f N1 N.
mm 3
l 1 2 r 2.
m1 m2 4. (A)
2. (C) Use linear momentum conservation.
10
rad/s2 = 5 rad/s2 5. (D)
2
Mass of the loop = M = L
1 2
I MR 2 0.2 0.02 kg m2 Further, if r is the radius of the loop, then
2
L
I 5 0.02 0.10 N m. 2r L r
2
3. (B)
Moment of inertia about XX ’ is
The force acting on the ladder are as
3
shown in the following figure. The forces l Mr 3
2
are its weight W, normal force N1 exerted
3 L2 3L3
by the vertical wall, normal force N2 l L 2
.
exerted by the floor and frictional force f 2 2 82
exerted by the floor. 6. (B)
Let h = height of ceiling from where ball was
drop
Speed by which ball hit the floor first time =
2 gh .
Speed after the first hit = e 2 gh .
Then, speed of the ball by which it hits the
Taking horizontal and vertical
floor for the second time = e 2 gh .
components, we get
N1 = f Speed after the second hit = e 2 2 gh .
(1) This speed is the initial speed u for upward
and N2 = W motion after second impact.
u2
(2) Now, the height attained = .
2g
Taking torque about B, we get 2
2
N1(AO) = W(CB) h e 2 gh e 4 2 gh
CB 2 2g 2g
or N1 W
AO 1
e .
or 4
2
BO W 4 W BO 4 7. (A, D)
As tan 53o
AO 2 3 2 AO 3 Linear momentum is not conserved due to
(3) the force exerted by hinge.
The normal force by the floor is
8. (A, C, D)
Net external force on the system is zero. 11. (A, C)
Therefore, linear momentum will remain The following figure depicts the situation.
conserved. Initially both the particle have
equal momentum iun opposite directions.
Hence, the initial momentum is zero, that
is, final linear momentum is also zero or
velocity of centre of mass vc = 0. The momentum of the system is 1 3 3
Let be the angular velocity about centre kg m/s; momentum of 3 kg after collision is
of mass. The net external torque on system 5 1 5 kg m/s. Thus, the kinetic energy
u is also zero. Hence, the angular of the centre of mass is
momentum about centre of mass will also 2
1 mu
be conserved, that is, m1 m2 1
2 m1 m2
Li L f 2mva 4mva l 2
1 1 3
1 5 0.75 J
2 6
6a 2 2
2
8m 2m a m 2a The total kinetic energy of the system is
12 calculated as
1
1 32 4.5 J.
6mva 24ma 2 2ma 2 4ma 2 2
12. (A, C)
30ma
2
v 13. (3)
5a l ml 2
mg .
Finally, 2 3
1 1 v 3
2 14. (2)
E l 2 30ma 2 mv 2 .
2 2 5a 5
9. (A, D)
L mv0 r sin
mg T ma (1)
T R l (2)
a
T R l
R
L mv0b constant
mR 2 a Ma
r1 r 2 r T R T (3)
2 R 2
1 From Eq. (1), we get
Now, dA v0 dt r sin
2 1
mg ma 1
dA mv0 r sin L 2
.
dt 2m 2m 3 2a
mg ma a
10. (A, D) 2 3
Kinetic energy changes during the
collision.
M 2 g mg 18. (8)
Now, from the equation, T ,
2 3 3
we get 19. (d)
0.6 10
T 2 N. a
3 p 2 V b RT
V
15. (2)
(a) If a = 0, for gas A
p V b RT
Percentage of an isotope atomic weight From question, 0.2 2x 0.04
100
2x 0.2 0.04 0.16; x 0.08
10.01x 11.01100 x
10.81 0.08 0.08
100 Kp 2
0.04
x 20%
Therefore, natural boron contain 20% 35. (9)
38. (B)
Let centre of the circles be C1 and C2
Clearly, OPCQ is cyclic quadrilateral, then
circumcircle of ΔOPQ passes through the
point C.
Since OP and OQ are tangents to the circle
they make perpendicular with CP and CQ
respectively. Also a circle inscribes two right
angled triangles which are COP and COQ in
this case. Thus for this circle, OC is a
diameter, then centre is midpoint of OC
41. (C)
which is (3/2, -1). 100
100
z 1 i 3 100
2 cos i sin
3 3
44. (B, C)
The given circles
are x 2 y 2 2x 0, x 0 and
x 2 y 2 2x 0, x 0
From the above figure, the centres of the
required circles will be 0, 3 and 0, 3
The equations of the circles are
2
x 0
2
y 3 12
42. (B)
x, y and z are in G.P. hence,
y xr, z xr 2
Also, x, 2y, and 3z are in A.P. hence,
4y x 3z 45. (A, C)
The point from which the tangents drawn are
4xr x 3xr2
at right angle lie on the director circle.
3r2 4r 1 0
Equation of director circle is
3r 1 r 1 0 x 2 y2 2 16 32
r 1/ 3 Putting x 2, we get
(r 1 is not possible as x, y, z are distinct) y 2 28
y 2 7
43. (A,C,D)
The points can be
x 2 y 2 8x 10y 40 0
Centre of the circle is (-4, 5) 2, 2 7 or 2, 2 7 .
Its radius = 9 46. (A,B,C)
Distance of the centre (-4, 5) from the point From figure,
(-2, 3) is 4 4 2 2
a 0
b b
4or 0
2a 2a
b0
f 0 c 0
b
Also, 4 or 8a b 0
2a
47. (A, B) 49. (2)
sin x
4
cos x
4
1 ab bc
Given, b2 ac and x ,y .
2 3 5 2 2
Therefore,
4 6
3 6 cos x 5 cos x
2
. Let cos x = t a c 2a 2c
5
x y ab bc
25t 4 30t 2 9 0
2a b c 2c a b
a b b c
2ac ab bc
2
ab ac b 2 bc
2ac ab bc
2
2ac ab bc
b2 ac
3 2 2
t2 tan 2 x
5 3 50. (5)
4 | z 3 2i | 2
8 2 16
sin x z lies on or inside the circle radius 2 and
5 625
4 center (3, 2)
8 3 81
cos x
5 625
8 8
sin
cos x
1
8 27 125
48. (A, C, D)
n
C1 n 1C2 n 2 C3 ... n m 1C m
n C n 1 n 1C n 1 n2
C n 1 ... n m 1C n 1
= Coefficient of
n n 1 n2
x n 1 in 1 x 1 x 1 x
n m 1
... 1 x | 2z 6 5i |min.
1 x m 1 2 | z 3 5 / 2 i |min.
n 1 n
= Coefficient of x in 1 x = 2 (minimum distance of any point on the
1 x 1
circle to the point (3, -5/2))
m n n
n 1 1 x 1 x = 2(5/2) = 5
= Coefficient of x in
x 51. (4)
m n n k
= Coefficient of x n in 1 x 1 x k k i
k cos i sin e7
7 7
m n
Cn 1 12 k 1 i k
12 i
Similarly, we can prove | k 1 k | e
k 1
7
e 7
k 1
3
4k 1 i 4k 2 i
3
m
C1 m 1C2 m 2 C3 ... m n 1C n m n
Cm 1 | 4k 1 4k 2 |
k 1
e 7
e 7
k 1
12 k i
i 12
e 7 e 7 1
k 1
1
k 1
4k 2 i
3
3 i
e 7
e 1 7 1
k 1
k 1
k
i
4k 2
i 12 Now, the distance of this point from the line
e 7
e 7
1 4 4x 3y 10 0 is 1. Therefore,
3
| 4t 3 4 t 10 |
52. (1) 1
5
or |t + 2| = 5
i.e., t = 3 or t = 7
Therefore, the sum of values is 4
54. (2)
The point B is (2, 1). The image of A (1, 2)
on the line x – 2y + 1 = 0 is given by
x 1 y 2 4
1 2 5
Hence, the coordinates of the points are (9/5,
2/5).
Since this point lies on BC, the equation of
BC is 3x – y – 5 = 0. Hence, a + b = 2.
53. (4)
Any point on the line x + y = 4 is (t, 4 – t),
where t R.