Professional Documents
Culture Documents
GENERAL DETAILS
COLOUR CONTRAST MAGNETIC PARTICLE EXAMINATION USING A/C ELECTROMAGNETIC
Title:
YOKE - MAGNETIC FLOW
Application: Welds ( + 25 mm from toes) , back gouges, preps, plate, pipe, cast & forged ferromagnetic materials
Qualifications: ASNT/PCN Level 2 or equivalent
Technique in Accordance with: ASME V: 2010 Article 7 and NDT-OPR-031 (See supervisor for latest revision)
Acceptance Criteria: To be specified prior to the commencement of test
TECHNIQUE AND EQUIPMENT
Permanent Magnet: N/A Waveform Current value
N/A N/A N/A
DC Electromagnet: Prods
N/A N/A
AC Electromagnet: Y6 Yoke or equivalent Contact Heads:
N/A N/A
Flux / Field Strength Indicator: Type 2 Burmah Castrol Strip Solenoid Heads:
N/A N/A
UV Light (if applicable): N/A Coil:
N/A N/A
Surface Condition: Free from extraneous material Threader Bar:
Temperature: Up 57ºC – above this – dry Viewing Conditions > 1000 lux at test surface (reduced to
Contrast Paint: Chemetal WCP720 Wet Non Fluorescent Ink: Chemetal Supramor 4
A C B E D G F
H
Test area
B D A F C H E
A C E
D D
B B F F
A C E
Additional Instructions:
• Reports to be produced on day of test, where possible.
• Note any restrictions on test report.
• Equivalent consumables or water based consumables may be used. Record the consumable used on the test report
• Technique can be applied to other types of forming e.g. castings as long as the same principles for coverage apply and the technician is
qualified in that sector.
Page 1 of 2
APPROVAL
xxxxxxxxx Client Third Party
Approved By: Approved By: Approved By:
Signature: Signature: Signature:
Date: Date: Date:
Page 2 of 2