This document specifies the requirements for an orifice to be installed in a boiler system. It lists 15 items describing the medium, flow rates, operating conditions, materials, location, testing requirements, line size, transmitter tapping size, quantity, and tag number. It notes that the differential pressure must be sufficient to measure 20% of the flow accurately. The supplier must provide details on the pressure drop, tappings, dimensional drawing, flow curves, and certificates with the offer.
This document specifies the requirements for an orifice to be installed in a boiler system. It lists 15 items describing the medium, flow rates, operating conditions, materials, location, testing requirements, line size, transmitter tapping size, quantity, and tag number. It notes that the differential pressure must be sufficient to measure 20% of the flow accurately. The supplier must provide details on the pressure drop, tappings, dimensional drawing, flow curves, and certificates with the offer.
This document specifies the requirements for an orifice to be installed in a boiler system. It lists 15 items describing the medium, flow rates, operating conditions, materials, location, testing requirements, line size, transmitter tapping size, quantity, and tag number. It notes that the differential pressure must be sufficient to measure 20% of the flow accurately. The supplier must provide details on the pressure drop, tappings, dimensional drawing, flow curves, and certificates with the offer.
W.O. No. Rev. NIL S. No. Description Specification 1 Medium Attempretor Water 2 Flow 8000 kg/hr Max 5000 kg/hr Nor 350 kg/hr Min 3 Operating temperature 110 DEG 4 Operating pressure 104 Kg/cm² 5 Design pressure 105 Kg/cm² 6 Differential pressure 0-6000 mmwc 7 Material of construction SS 316 8 Location In between Flange 9 Test IBR 10 Line size 40NB SCH 80 sch 80 11 Material of pipe SA 106 Gr B 12 Design code BS 1042/Equt. 15 NB (Socket weld) 2 pair of tappings to be provided. In this I should be 13 Transmitter tapping size plugged with suitable material. 14 Quantity 1 No. 15 Tag No 1FE 102 Note: Supplier to confirm the differential pressure will be sufficient. 1 This flow measuring device should be in a position to measure flow at 20% of flow accurately 2 as signals are being taken for some controls. SUPPLIER TO FURNISH THE FOLLOWING WITH OFFER 1 Permanent pressure drop across orifice. 2 Tapping detail 3 GA drawing with dimensional details 4 Q vs H curve (with temp. compensation curves) 5 Technical data sheet DOCUMENTS REQUIRED FROM SUPPLIER 1 Test certificate 2 IBR certificate 3 6 sets of O & M manual