Professional Documents
Culture Documents
Overall dimensions of ElectropaK • derate tables for increased ambient temperature and/or altitude
are available, please contact Perkins Applications Department.
Height, including radiator support brackets .. .. ... .. ... .. ... .. ... 1426 mm
Length, front of radiator to rear of air cleaner.. .. ... .. ... .. ... .. . 1878 mm
Test conditions
Width .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. 949 mm
Air temperature .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... 25°C
Moments of inertia (MK²) Barometric pressure .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . 101 kPa
Engine rotational components .. .. ... .. ... .. ... .. ... .. ... .. ... 0.4269 kgm² Relative humidity.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . 10.7 %
Flywheel .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . 1.26 kgm² Air inlet restriction at maximum power (nominal).. .. .. . .. .. . .. .. . .. .5 kPa
Exhaust back pressure at maximum power (nominal).. .. ... .. ... . 15 kPa
Centre of gravity
Fuel temperature (inlet pump).. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. . 40 °C
Forward from rear of block.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... 476 mm
All ratings certified to within.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . ± 3%
Above centre line of block .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... 199 mm
1 of 4
Publication No. TPD2127, March 2018.
Copyright © 2018 Perkins Engines Company Limited, all rights Perkins Engines Company Limited
reserved. No part of this document may be reproduced in any form Peterborough, PE1 5FQ, United Kingdom
or by any means, without prior written permission of Perkins Engines Tel: +44 (0)1733 583000
Company Limited. The information in this document is substantially Fax: +44 (0)1733 582240
correct at the time of printing and may be altered subsequently. www.perkins.com
General installation
Engine speed @ 1500 rpm Engine speed @ 1800 rpm
Designation Units
Prime (50Hz) Standby (50Hz) Prime (60Hz) Standby (60Hz)
Exhaust gas flow (maximum) at atmospheric pressure m³/min 24.23 26.58 28.14 30.82
Energy balance
Engine speed @ 1500 rpm Engine speed @ 1800 rpm
Designation Units
Prime (50Hz) Standby (50Hz) Prime (60Hz) Standby (60Hz)
2 of 4
Publication No. TPD2127, March 2018.
Copyright © 2018 Perkins Engines Company Limited, all rights Perkins Engines Company Limited
reserved. No part of this document may be reproduced in any form Peterborough, PE1 5FQ, United Kingdom
or by any means, without prior written permission of Perkins Engines Tel: +44 (0)1733 583000
Company Limited. The information in this document is substantially Fax: +44 (0)1733 582240
correct at the time of printing and may be altered subsequently. www.perkins.com
Cooling system Fuel specification
USA Fed Off Highway.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... ASTM D975
Total coolant capacity Europe Off Highway.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. EN590
ElectropaK (with radiator) .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... 25 litres
ElectropaK (without radiator) .. .. ... .. ... .. ... .. ... .. ... .. ... .. .. 13.7 litres Note: or further information on fuel specifications and restrictions,
F
Maximum top tank temperature .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... 108°C refer to the OMM fuels section for this engine model.
Maximum static pressure head on pump.. .. ... .. ... .. ... .. ... .. ... 70 kPa
Temperature rise across engine.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. 8 °C Fuel consumption
Maximum permissible external system resistance .. .. ... .. ... .. ... 35 kPa
Thermostat operation range.. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. 82-93°C 185.8kW/1500 rpm Prime
Power rating %
g/kWh litres/hr
Radiator
25 237.2 13.1
Radiator face area .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . ..0.444 m²
Material and number of rows.. .. ... .. ... .. ... .. ... .. ... .. ... Aluminium 57 50 212.4 23.5
Material and fins per inch .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. 10 75 208.9 34.7
Width of matrix .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. 550 mm 100 206.9 45.8
Height of matrix.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . 800 mm
Pressure cap setting .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . 100 kPa 110 209.7 51.0
Fan
Type.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. .. Pusher Fan 216.6kW/1800 rpm Prime
Power rating %
Diameter .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. . 724 mm g/kWh litres/hr
Number of blades.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... ..7 25 257 16.5
Material.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... Heramid & Steel
50 216.4 27.8
Drive ratio .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ..1.33:1
Airflow at rated speed.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... 4.42 m³/min 75 209.3 40.4
200 kWe (60Hz) 50 200 5.62 -20°C 10W40 1650 10W40 (1)
Type of injection .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. Common Rail Note: Glow plugs needed below -10°C.
Fuel injection pump.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. . Denso HP4 Note: For cable sizes see Applications and Installation Manual.
Fuel injector .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... Denso G3S
1. Must use glow plugs.
Nozzle opening pressure .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. 5 Mpa
Maximum particle size .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . 4 Microns
Fuel lift pump type.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. Brushless Electric
Flow/hour.. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. 3.5 Litres/hour @ 200 kPa
Pressure .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. .400 kPa
Maximum suction head .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .-30 kPa
Maximum static pressure head.. .. ... .. ... .. ... .. ... .. ... .. ... .. ...500 kPa
Maximum fuel temperature at lift pump inlet.. .. .. . .. .. . .. .. . .. .. . .. . 75 °C
Maximum fuel filter service interval .. .. ... .. ... .. ... .. ... .. ... .. 500 hours
Governor type .. .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. . .. .. Electronic ECM
Speed control conforms to.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... N/A
3 of 4
Publication No. TPD2127, March 2018.
Copyright © 2018 Perkins Engines Company Limited, all rights Perkins Engines Company Limited
reserved. No part of this document may be reproduced in any form Peterborough, PE1 5FQ, United Kingdom
or by any means, without prior written permission of Perkins Engines Tel: +44 (0)1733 583000
Company Limited. The information in this document is substantially Fax: +44 (0)1733 582240
correct at the time of printing and may be altered subsequently. www.perkins.com
Lubrication system Electrical system
Alternator....................................................................100 amps/12 volts
Total system capacity
Starter motor...................................................................... 5 kW/12 volts
Maximum sump capacity............................................................ 16 litres Number of teeth on flywheel..............................................................134
Minimum sump capacity............................................................. 13 litres Number of teeth on starter pinion.........................................................13
Maximum oil temperature (continuous operation)..........................125°C Engine stop method.........................................................................ECM
Maximum oil temperature (intermittent operation).........................135°C
Front up, front down, right side or left side.......................................... 30° Initial load application: When engine reaches rated speed
(15 seconds maximum after engine starts to crank)
Recommended SAE viscosity
Description Units 60 Hz 50 Hz
A single or multigrade oil conforming to API-CH-4 or ACEA E5 must be used.
Prime power % 67 75
Viscosity grade
Load kWm 138 131
15W-40
10W-40 Frequency recovery Seconds 0.7 0.95
10W-30
5W-40
The figures shown in the table above were obtained under the following
5W-30 test conditions:
0W-40 Engine block temperature .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. . 90°C
0W-30 Ambient temperature .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. . 25°C
-50 -40 -30 -20 -10 0 10 20 30 40 50 60
Governing mode .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ...0 %
Alternator inertia .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... . 7 kgm²
Ambient temperature °C
Under frequency roll off (UFRO) point set to .. 20 %volt/10 %Frequency
LAM on/off .. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. off.
Induction system Note: ll tests were conducted using an engine installed and serviced
A
to Perkins Engines Company Limited recommendations.
Maximum air intake restriction of engine
Note: Derate curves for altitude and humidity can be found in
Clean filter.. .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ... .. ...3 kPa Engine Specification Manual.
Dirty filter.........................................................................................8 kPa. Note: The general arrangement drawings shown in this data sheet
are for guidance only. The latest versions should be requested
from the Perkins Applications Department.
Exhaust system
Exhaust outlet size........................................................................80 mm
Minimum back pressure................................................................25 kPa
Maximum back pressure...............................................................35 kPa
4 of 4
Publication No. TPD2127, March 2018.
Copyright © 2018 Perkins Engines Company Limited, all rights Perkins Engines Company Limited
reserved. No part of this document may be reproduced in any form Peterborough, PE1 5FQ, United Kingdom
or by any means, without prior written permission of Perkins Engines Tel: +44 (0)1733 583000
Company Limited. The information in this document is substantially Fax: +44 (0)1733 582240
correct at the time of printing and may be altered subsequently. www.perkins.com