Start with the Flange.SLDPRT part you made in Lesson 05 and make it’s corresponding 2D drawing as shown below in SolidWorks.
Introduce 2 Dimensional Detail/Component Drawing from 3D part models.
See MS word doc “Lesson 14 2D DRW from 3D Part.doc” for greater detail instructions. Start with Front View, Top View and the Isometric View. Make the Section View J-J Add the Centre Lines and Dimensions (look at tolerances, fits and Geometric tolerances later) Save the drawing as Flange.SLDDRW in the same folder as Flange.SLDPRT Sheet Format is SolidWorks’ name for Title Block. Customize the Title Block as below using Links to File Properties (See “Lesson 14 Altering Title Block.doc”).