Maintenance Mode Change a The following items can be selected on
The operating condition for maintenance function in the Change of maintenance mode screen. the operation mode can be set and changed with 01 Engine oil change this menu. 02 Engine oil filter change q Set function effective or ineffective 03 Fuel main filter change q Change set replacement interval (by items) 41 Fuel pre-filter change q Initialize all set replacement intervals 04 Hydraulic oil filter change 1. Selecting menu 05 Hydraulic tank breather change Select of “Maintenance Mode Change” on the 06 Corrosion resistor change “Service Menu” screen. 07 PTO case oil change 08 Final drive case oil change 09 Machinery case oil change 10 Hydraulic oil change 30 Hydraulic oil pilot filter change 31 Hydraulic oil drain filter change 42 Oil cooler accumulator change
3. Contents of setting of Maintenance mode on/
off After selecting “Maintenance Mode On/Off”, if the screen is displayed, set ON or OFF with the function switches. q ON: Functions of all maintenance items are set effective in operator mode 2. Selecting sub menu q OFF: Functions of all maintenance items After the “Maintenance Mode Change” screen are set ineffective in operator mode is displayed, select an item to change the set- q [F3]: Move to lower item ting with the function switches or numeral input q [F4]: Move to upper item switches. q [F5]: Cancel selection and return to Main- q [F1]: Move to next page (screen) tenance mode change screen q [F2]: Move to previous page (screen) q [F6]: Confirm selection and return to q [F3]: Move to lower item Maintenance mode change screen q [F4]: Move to upper item a Even if ON/OFF of each item has been q [F5]: Return to service menu screen set, if the above setting is changed, it is a You may enter a 2-digit code with the applied. numeral input switches to select the item of that code and confirm it with [F6].