‘Number : 2014-02-002 ARKRAY Infinity, Inc.
TEL +81-748-86-8732 FAX +81-748-86-8739
Technical Information
Number: 2014-02-02 Date:24/February/2014 Page: 1 of 2
Products : HA-8180 series Serial# / Lott: (ALL)
L.Mechanical Electrical) 3. Reagent 4. Software 5. Others
Subject: Sample tube spinning unit front/rear motor connector position
1. Reason for Change
When the sample tube spinning unit motor connector position is not proper, short-circuit can be induced # fluid
leakage occurs inside the instrument and the connector is splashed with spilt fluid.
In this Technical Information, appropriate connector position is explained. Check and correct the connector
positon.
2, Details
4. Details
HA-8180 family instruments are designed to let a tube disconnect intentionally at the place where the risk
is low, when the internal pressure in tube is increased by tube clogging or blockade. Measurements can be
possible while the tube is disconnected. (Refer to the Fig,1 and Fig2)
However, when the position of the sample tube spinning unit assembly front/rear motor connector is not
appropriate, liquid leaked from the instrument spills over the connector and it makes motor disorder. In
some cases, it short-circuits and burns. Note that the materials used for the instrument are incombustible,
and do not fire even though they may burn or smoke.
Fig.1 Instrument front bottom Fig.2 Instrument right side
2. Action required for shipped instruments
When visiting instrument users for repair or maintenance, check and correct the position of the connector
located at the bottom of the sample tube spinning unit assembly as fig.4. Ensure that the connectors NOT
contact the instrument bottom.
Fig.3 Sample tube spinning unit assemb!
ARKRAY Technical SupportNumber : 2014-02-02 ARKRAY Infinity, Inc.
TEL +81-748-86-8732 FAX +81-748-86-8739
Page: 2 of 2
‘White and yellow cables | _[ Ciamp brown cables at two locations.
Orange and red cables
Connect connectors.
Then place cables
through the clamp,
Fig.4 Connector position of the sample tube spinning unit assembly bottom part.
3.Affects on Inventory Control
Part Number Description Effective Lot_| Compat
NA N/A NIA NA
‘Compatibility: Use,Rework,Scrap,N/A
ity
4. Approved by
4.Marketing: Yoshiaki Shibuta S Fas Qoe Date: 27 Fos, off
2. Development: Takeshi Takagi Sik ofe céhkase Date: 24 Feh e/g
3.Technical Support: Fumio Yamauchi /Uiniio Lamauoh, Date: 2 Zeb 20/
ARKRAY Technical Support