Professional Documents
Culture Documents
Epoxy Primer
July 2007
DESCRIPTION APPLICATION
POLYFLOOR PFP – 211 is a two component solvent free Mixing ratio (by weight) :
amine cured epoxy primer formulated as a high build - As a primer coat, Comp A : Comp B = 4 : 1
- As a epoxy filler, (Comp A + B) : Filler F-01 = 1 : 3 – 4,
epoxy primer for concrete floor.
depending concrete damaged condition.
Pot life : 30 minutes (30° C)
Thinner : Thinner Epoxy for tools
USES cleaning
Application method :- Brush, roller (for primer coat)
This product excellent if used for primer coat in epoxy floor - Spatula (for epoxy filler)
repainting. Viscosity of mixture
Also it can be applied as epoxy filler for concrete patching (DIN Cup 4) : 25 sec
repair when mixed with POLYFLOOR Filler PFT – 350, talc or Re coating interval : Minimum 12-16 hours (30° C)
Application temperature : Minimum 10° C
quartz sand for big holes.
Maximum 35° C
Humidity maximum : 80 % RH
- Solvent free
- Excellent bonding strength SURFACE PREPARATION
- Good penetration
Compressive strength of concrete floor must be more than 25
- Easy application
N/mm². Direct trawl finish concrete without cement render is
the best surface condition for epoxy flooring. Age of concrete
should be more than 28 days and moisture content should be
PRODUCT DATA less than 5%. The temperature of the substrate must be at least
3°C above the current dew point temperature. Correct substrate
Type : Two component solvent less preparation is critical for optimum performance. Surface must
amine cured epoxy primer be structurally sound, clean, and free from loose particles, oil,
Color : Grey grease, and all other contaminants. Remove oil, grease and
wax contaminant by scrubbing with industrial grade detergent
Finish : Matt
or curing membrane and other contaminants must be removed
Solid by volume (mixture) : 96 %
from surface by shot blasting, scarifying or grit blasting
Specific gravity (mixture) : 1.50 followed by vacuum cleaning. After pretreatment of the
Material consumption : 0.15 – 0.20 kg/m² substrate, the bonding strength of the substrate must be at
(depending substrate condition) least 1.5 N/mm².
Flash point : 99° C
Bonding strength : ≥ 2.5 N/mm² (concrete failure)
Drying time : DIRECTION FOR USE
1of2/01.PFP 211(Rev).doc
RECOMMENDED COATING SYSTEM
SAFETY PRECAUTIONS
This does not contain any material with heavy metals such as
lead. Avoid contact with the skin and eyes. Wear suitable
protective clothing such as overalls, goggles, dust masks and
gloves. Use barrier cream. This product is flammable. Do not
smoke. Use only explosion proof equipment. Do not breathe
vapour or spray.
First Aid :
CLEANING
Notes :
The technical details and recommendations contained in this technical data sheet are given to assist our customers and correspond to the best of our
knowledge and experience correct at the date printing. Anyone who intends to use the product must ensure beforehand that it is suitable for the
envisaged application in every case.
The company reserves the right to modify data without notice. The data should only be used after checking with our nearest office to ensure that
they are still valid. This Technical data sheet is made without guarantee since the conditions of use are beyond our control.
2of2/01.PFP 211(Rev).doc