Professional Documents
Culture Documents
Project Members
A.Nijamdeen
921711112023
S.Thangappandi
921711112041
S.Vivek Chellapperumal
921711112049
Guided by
Mrs.V.Petchithai
(AP/ICE)
Overview
•Abstract
•Existing method
•Proposed method
•Result
•Future Enhancement
•Conclusion
Abstract
• In present days people are driving very fast, accidents are occurring
frequently and we are losing valuable life by making small mistake while
driving.
• So to avoid such accidents in school zone, hills area, highways we are
implementing this project
• In this we are using an Smart Display and Controller for vehicle’s speed
control and monitors
Existing Method
• Mostly there are no sign boards are used to indicate the school zone
,hospital area.
• No technical alerting system is required.
Proposed Method
• Here we are using Smart Display and Controller technique to reduce the
vehicle’s speed automatically in the area of School zone, hills area used
the RFID transmitter and receiver.
• By sensing the transceiver signal vehicles receiving unit will helps to
control and decrease the speed automatically
• It includes the indicating board to RFID transceiver
Tools Used
Hardware:
• PIC Microcontroller
• DC Motor and its Driver Circuit
• Power Supply Unit
• 2*16 Liquid Crystal Display
Software:
• MPLAB Integrated Development Environment
• PIC C Compiler
• IC Programmer
Block Diagram
Implementation
• The SDC is composed of two separate units: zone status transmitter unit
and receiver unit.
• The transmitter modules operate with a carrier frequency of 433MHz.
• Once the information is received from the zones, the vehicle’s embedded
unit is automatically alert the driver, to reduce the speed according to the
zone, it waits for few seconds, otherwise vehicle’s SDC unit automatically
reduce the speed.
Zone Status Transmitter Unit :
• It has RF transmitter and Encoder is located at the zone (School zone, Hospital zone and
etc..,).
• It generates the RF signal.
Receiver Unit:(Vehicle Unit)
• It has RF receiver, to PIC Microcontroller and is Embedded programmed to Drive the DC
Motor using Motor Driver
• If transmitting signal is available on the receiver side , the signal is decoded by the
decoder by means of the RF signal is converted to controller language, then it is given to
Microcontroller and the microcontroller is always programmed to drive motor for
minimum speed.
ADVANTAGES
• It helps to reduce most of accidents oocurs in schools and hospital zones
• Our project may also helpful for the peoples to drive safely without their
knowledge
• Because of using microcontroller the cost of this project is low to
implement it in a vehicle
RESULT-HARDWARE SNAPSHOT IN OFF STATE
RESULT-HARDWARE SNAPSHOT IN ON STATE
Future Enhancement
Conclusion