Professional Documents
Culture Documents
Training On E&E: July 2012
Training On E&E: July 2012
July 2012
Resistance
Switch
= 0
Gates
Inputs
a b
AND ab OR a+b
The output c
NAND ab NOR a+b NOT XOR ab a
1 1
0
1 1
1
0 1
0
0 1
1
1 1
1
1 0
0
0 0 0
1
1 0
Relays
Relay
Relay
Ohm's Law
Problems:
Draw circuit diagram for Basic gates. Draw a circuit for door bell. Draw a circuit for water level controller.
Advance E&E
12VDC Start 0 VDC
Stop
Thank you
Function details
Example : Step 1
Step 2
Determine the Related Symptoms: 1. How much of the circuit is affected Check fuses, loads on same fuses. 2. Find the clues to the location of the problem by operating other circuits related or connected to the problem area. Check Power, ground
Step 3:
Analyze the symptoms : 1. Exactly which components /circuits are affected 2. What kind of problem to look for 3. When it occurs.
Step 4:
Isolate the Problem: 1. Find the possible problem areas 2. Where to begin 3. Process of elimination
Step 5:
Correct the trouble : 1. Repair or replacement of a component 2. Wiring repair 3. Service to a circuit connection
a. Connector. b. Terminal. c. Ground Point.
Step 6:
Check for proper Operation: Verify of the problem is fixed.