4.2 Procedure Part A: Basic Wheatstone bridge control circuit test
Construct the circuit shown with R1 = R2 = R3 = 510 , Rb= 33 , Rc= 200
, E1=5 V, E2=3 V. Adjust the resistor Rd until the bridge is balanced (Vab= 0), then increase it in 20 increments up to 810 . Record the voltage Vab and the collectors current Ic. Rd ()
r=Rd-510 ()
Vab (V)
Ic (mA)
Plot Vab vs. resistance changes r , and Ic vs. r
Part B: Basic Wheatstone bridge
control circuit design Measure the photo-conductive cells resistance Resistance in light () Resistance in dark ()
Using the measurements above, design a circuit that controls a LED, so
that the LED is ON when it is dark. Vab vs. Ic vs. R1= R2= R3 ()