Professional Documents
Culture Documents
1. H7 / g6 is a ……… fit.
(a) Clearance (b) Interference
(c) Transition (d) All the above
3. When diameter is controlled by circular runout, its maximum possible offset from the
datum axis is equal to ……… the runout tolerance value
(a) Same as (b) Double
(c) Half of (d) None of above
(a) Difference between LMC of mating features (b) Difference between MMC of mating features
(c) Difference between shaft MMC and hole LMC (d) Difference between shaft LMC and hole MMC
14. Whenever a straight control is associated with FOS dimension applies to the
…………… of FOS
(a) Axis (b) Center plane
(c) Axis or center plane (d) None of above
15. ……………………. is the only geometric control that can override Rule # 1
(a) Straightness of an FOS (b) Flatness
(c) Perpendicularit (d) Circularity
17. When perpendicularity applied to surface, the shape of tolerance zone is …………
planes that are perpendicular to the datum plane(s)
(a) Two parallel (b) Two perpendicular
(c) Two inclined planes at an angle (d) None of the above
18. When perpendicularity is applied to surface, the zone of tolerance indirectly limits
the…………….. tolerance zone.
19. When angularity applied to a surface, ……………. of the surface elements must be
within the tolerance zone.
(a) Only one (b) All
(c) Two (d) None of the above
20. A ………. is a geometric tolerance that limits the amounts a surface, axis, or center
plane is permitted to vary from being parallel to the datum.
23. If “Controlled Radius” modifier is given, the part surface flats or reversals have ............
the tolerance zone
(a) Without (b) Within
(c) Zero (d) None of the above