Professional Documents
Culture Documents
1. Un clause
2. Fire hose standard ( 12,16,19)
3. Oil discharge cargo residue ( 1/30000)
4. Following certificate for 5 years (smc)
5. Ro ro type which type of extinguisher ( low expansion)(12:1) (1000:1for high)
6. Metacenter height ( GM)
7. Height of centre of gravity (KG)
8. CPR (15:2)
9. OWS ALARM (15PPM)
10. CPR (chest comp 11/2 TO 2)
11. COW ( OPERATION & MAINTENANCE MANUAL)
12. ODMS DISHCHARGE HOW LONG..(3YEARS)
13. LIFEBOUY SMOKE SIGNAL TIME 15 MIN LIGHT SIGNAL 2 HOURS
14. COMPANY FOLLOWING ISM (DOC- COMPANY) (SMC-SHIP)
15. COASTAL AREA 200 KNOTICAL MILE CONTINENTAL SHELL( BEFORE 200 ECONOMICAL)
16. FOAM BOTTLE 9 KG
17. CO2 DISADVANTAGE-less cooling effect
18. NOT FALSE ( CARGO RESIDUE CAN BE DISCHARGE WITHIN 12 KN/M)
19. REQ OF DISCH( 150 GT & 400GT)
20. FUEL OIL TANK CAPACITY 2500M3
21. PYROPHORIC ( SPONTANEOUS O2 AUTO IGNITION)
22. LONDON CONVENTION
23. A506-
24. A602- RELATED TO GUIDELINE OF PORTABLE EXTIGUISHER
25. IGG- ALARM 5% TRIP 8%
26. EXPLOSIMETER 21% LEL
27. TOXIMETER
28. CHEMICAL FOAM DEGRADISATION ( MIXING)
29. REFER CYCLE ARRANGEMENT
30. ISPS (SOLAS CHAPTER 11 PART 1&2)
31. RADIO COMMUNICATION GMDSS( CHAPTER IV)
32. VDR AIS CHAPTER V
33. PLASMA REDUCTION DUE TO GREES HOUSE EFFECT
34. EEDI –GREEN HOUSE EFFECT
35. LIFE BOUF ( UNDER 100 M LONG
36. IN WHCH TNK CANNOT TAKE OIL- FWD PEAK TANK
37. CO2 85% IN 2MIN
38. MECHANICAL FOAM FORMATION – AIR WATER…..
39. DETENTION OF FIRE FIGHTING – STATION BILL
40. CARGO PUMP ROOM BEFORE ENTERIN VENTILATION SHOULD BE 30 MIN
41. IF UN CONCIOUS – UN CLOTHING
42. IMMERSIONSUIT 2MIN
43. LIFEJACKET 1 MIN
44. HULL PAINT – NON TOXIC
45. BALLAST SEA CONDITION – SEQUENTIAL TYPE
46. FIRE P/P PREESURE CARGO 2.7 PASS 3.2
47. DEEP PROTECTION CAPACITY -600 M3
48. MARPOL HEAD- ASSEMBLY
49. AIAS-CHANNEL4
50. AIAS & LLIR – RANGE DECREASES
51. DCP STD SIZE – 5KG
52. LIFEBOAT UNDER COMES WHICH CERTIFICATE… safety equipment certificate
53. NON MANDATORY CODES-BLU
54. HONGKONG CONVETION
55. SINGAPORE CONVECTION –AIR
56. MANILLA –STCW 2010
57. NAIROBI 0– REMOVAL OF WRACK
58. SEWAGE DISCHARGE CRITERIA 3 nm treated and 12 nm untreated
59. INTERNATIONAL SHORE CONNECTION id-64mm od 178 pcd 132 flange thickness 14.5 mm
4 bolts n nuts
60. BILGE CONNECTION
61. LIFE BOUY LIGHTIN 2 HOUR
62. LIFERAFT 12 HOUR
63. LIFE JACKET 50 per min FLASH CONTINUOUS
64. DCP WHICH TYPE OF REACTION – CHAIN REACTION
65. POSITION OF FUEL TANK ACCORDING TO WHICH ANNEX- ANNEX 1
66. SIZE OF SEA WATER SUC PIPE-
67. CAN WE PUMP OUT ER BILGE- YES
68. WHICH CONVENTION ADOPTED BY IMU-
69. FD FAN IGG TRIP –LOW WATER LEVEL IN SCRUBBER
70. SIZE OF FIRE HOSE – 15 M IN ER .. 20 M IN DK
71. EMERGENCY DG STARTED … 45sec
72. LIFEBOAT STARTIN REQ- 2 BATTERY .. BY MEANS OF 2 START
73. NO OF LIFE BOUY REQ DEPEND UPON LENGTH
74. SEGREGATE BALLAST TNK
75. BILGE TNK REQ
76. MARPOL DEF
77.
2.In which of the following documents on board, authentic information about the
circumstances and procedures to obtain Radio Medical Advice can be found?
A.Safety Management Manual
B.The Ship Captain's Medical Guide
C.First Aid Booklet
D.Code of safe working practices
3.Which of the following documents carried by a ship is not issued under the SOLAS
convention?
A.Fire control plan/booklet
B.Maneuvering booklet
C.Minimum safe manning document
D.Records of hours of rest
4.When using the rainwater collection tubes on a liferaft, the FIRST collection should be
A.passed around so all can drink
B.poured overboard because of salt washed off the canopy
C.saved to be used at a later time
D.used to boil food
5.Which of the following is not an exception provided under MARPOL, Annex-1, regarding
the discharge of oil or oily mixture into the sea?
A.Discharge for the purpose of securing safety of a ship
B.Discharge for the purpose of saving life at sea
C.Discharge resulting due to damage to the ship because of Master???s fault even if the
Master/Owner of the ship has taken all reasonable precautions to prevent/minimize
discharge
D.Discharge resulting due to damage to the ship not because of Master???s fault, but
because of a third party???s fault and action awaited by Master from that third party to
prevent /minimize discharge
6.Under OPA 90, who is responsible for mobilizing Oil Spill Removal Organization (OSRO), in
the event of spill of oil or Noxious liquid Substances?
A.Master
B.USCG
C.Qualified Individual
D.Technical Superintendent
7.As per definition of MARPOL Annex-1, a Crude oil tanker means a tanker designed to
carry:
A.Crude oil and other dirty oils
B.Crude oil alongwith some refined products
C.Crude oil only
D.Crude oil, but alternatively may carry at times dirty and clean oil products also
A.13.5 Kgs
B.23 Kgs
C.9 Kgs
D.46 Kgs
A.CLC 1992
B.Fund convention
C.LLMC
D.OPA 1990
11.If you observe any situation which presents a safety or pollution hazard during fuel
transfer operations on a MODU, which of the listed actions should be taken first?
12.As per the definition of MARPOL, Annex-1, a combination carrier means a ship designed
to carry:
A.Crude oil and refined oil products at the same time in different tanks
B.Refined oil products and chemical products at the same time in different tanks
C.A combination of different products at the same time, sometimes also known as a parcel
tanker
D.Either oil or solid cargoes in bulk
13.As per Marpol requirements, Every crude oil tanker of ______________ tones
deadweight and above delivered after 1st June 1982, shall be fitted with a cargo tank
cleaning system using _______________
A.5000, Sea Water Washing
B.10000, Fresh Water Washing
C.20000, Crude Oil Washing
D.30000, Bilge Water Washing
14.As per requirements of Marpol Annex -1, all ships of 400 gross tonnage and above:
A.Can carry fuel oil in fore peak, aft peak tanks and deep tanks
B.Cannot carry fuel oil in fore peak tank
C.Can carry fuel oil forward of collision bulkhead or aft of machinery space forward
bulkhead, but not in the cargo area in case of tankers
D.Cannot carry more than 600 m3 of oil fuel in any single fuel tank
.
20.To prevent oil from escaping into the sea when ballasting through the cargo piping
system, you should FIRST
22.Which of the following documents carried by a ship is not issued under the MARPOL
convention?
A.IOPP certificate
B.Oil Record Book
C.SOPEP
D.Safety Management Certificate.
23.When a vessel is floating upright, the distance from the keel to the metacenter is called
the
A.metacentric differential
B.height of the baseline
C.height of the metacenter
D.righting arm
24.Voyage data recorders (VDR) or simplified voyage data recorders (S-VDR) are required to
be installed on board certain ships as per_____________
A.ISPS code
B.ISM code
C.Chapter V of Solas
D.None of the above
A.Sea anchor
B.Fishing tackle
C.Drinking water cans
D.Life Jacket
26.As per STCW code, the abilities specified under standards of competence are grouped
under _______ functions, for the purpose of issuing certificates of competency.
A.Seven
B.Four
C.Six
D.Three
27.Under which IMO convention is Voyage Data Recorder- Certificate of compliance issued?
A.COLREG 1972
B.SAR 1979
C.SOLAS 1974
D.SALVAGE 1989
28.As per definition of MARPOL Annex-1, a product tanker is one which can carry:
30.In the first 24 hours after abandoning a vessel, water should be given only to personnel
who are
A.thirsty
B.sick or injured
C.wet
D.awake
32.In which of the following conditions, the IG blower fans should shut down automatically?
33.The stretcher normally used for rescue of casualties from engine room spaces, holds,
pump-rooms etc., is known as _____________________
A.Williamson stretcher
B.Neil Hobson stretcher
C.Neil Robertson stretcher
D.Stokes stretcher
34.As regulation 12 of Annex 1 of MARPOL, all ships of __________ gross tonnage and
above shall be provided with a sludge tank for collection of oil residues
A.150 tonnes deadweight
B.150 gross tonnage
C.400 tonnes deadweight
D.400 gross tonnage
35.Life buoy self-activating smoke signals should emit smoke of visible colour for at least
______________ in calm waters.
A.5 minutes
B.15 minutes
C.30 minutes
D.60 minutes
37.Divisions constructed of steel which can withstand a standard fire test for 30min without
passage of flame or smoke are classified as____________________
Personnel who are moving or handling material aboard ship should NOT follow which of the
listed practices?
A. Signaling that all personnel are clear before lifting or lowering material.
B. Examining material for sharp edges or protruding points before handling.
Closing, tagging, or securing valves that permit entrance of steam, water, or air into
C.
a fitting or other equipment.
D. Throwing materials from high places to the deck.
Rolling is the angular motion of the vessel about what axis?
A. Longitudinal
B. Transverse
C. Vertical
D. Centerline
When entering a compartment which is on fire,
A. you must wear rubber gloves
B. the flames should be beaten back from the door with water fog
C. a straight stream of water should be used to cool the door
D. a straight stream of water should be used to cool the fire fighters
As per MARPOL annex-1, the ???instantaneous rate of discharge of oil content??? means:
The rate of discharge of oil-water mixture in litres per hour at any instant divided
A.
by the speed of the ship in knots at the same instant
The rate of discharge of oil in litres per hour at any instant divided by the speed of
B.
the ship in knots at the same instant
The average rate of discharge of oil-water mixture in litres per hour divided by the
C.
average speed of the ship in knots
The average rate of discharge of oil mixture in litres per hour divided by the
Which of the following statements is false?
A. A ship security plan is made by the CSO
B. A ship security plan is a confidential document.
C. A ship security plan needs to be approved by the flag state administration
D. None of the above
When the height of the metacenter has the same value as the height of the center of gravity,
the metacentric height is equal to
A. height of the metacenter
B. height of the center of gravity
C. same as half the height of the metacenter
D. zero
A fuel tank on a barge has been certified by a marine chemist as being "Safe for Men" and "Safe
for fire". This condition may change if:
A. the ambient temperature changes
B. a product leaks into the certified tank
C. muck, sludge, or scale in the tank give off additional vapors
D. all of the above
Where would you find a list of the lifesaving equipment onboard your supply boat?
A. Ship's articles
B. Station bill
C. Certificate of Inspection
.
Plasma reduction system is a secondary method of reduction of which of the following kinds of
emissions?
A. SOX
B. Greenhouse gases
C. NOX
D. All of the above
In which of the following documents on board, authentic information about the circumstances
and procedures to obtain Radio Medical Advice can be found?
A. Safety Management Manual
B. The Ship Captain's Medical Guide
C. First Aid Booklet
D. Code of safe working practices
Back flow towards machinery spaces of cargo vapours in an Inert gas system is prevented
by_____________________
A. Pressure vacuum breaker
B. High velocity vents
C. Deck water seal
D. Pressure vacuum valves
As per requirements of Marpol Annex -1, all ships of 400 gross tonnage and above:
A. Can carry fuel oil in fore peak, aft peak tanks and deep tanks
B. Cannot carry fuel oil in fore peak tank
Can carry fuel oil forward of collision bulkhead or aft of machinery space forward
C.
bulkhead, but not in the cargo area in case of tankers
D. Cannot carry more than 600 m3 of oil fuel in any single fuel tank
Which of the following is not a requirement under MARPOL Annex VI, for new engines?
All engines above 130 KW to be tested and issued with EIAPP certificate and Nox
A.
Technical file.
Life boat engines and emergency diesel engines to be also tested and issued with
B.
EIAPP certificate and Nox Technical File
Periodical verification of EIAPP certificate is mandatory even when there has been
C.
no modification in the engine
Engines installed prior to the Nox technical code being applicable will not be
D.
subject to certification and testing unless they undergo major conversion
Which of the following statements is true?
Ballast water exchange at mid ocean eliminates completely the risks associated with
A.
introduction of non-native organisms and pathogens in alien habitats.
In the flow through method, the water pumped through a tank should be at least 3
B.
times the tank volume.
C. Over pressurization of a tank cannot take place during the flow through method.
D. Air pipes on ballast tanks are designed for continuous overflow.
When administering only mouth-to-mouth resuscitation, you should continue the victim's
ventilation rate at how many inflations per minute?
A. 4
B. 8
C. 12
D. 20
An oil record book Part-I shall be retained onboard for a period of:
A. 1 year since the last entry has been made
B. 1 year since the first entry has been made
C. 3 years since the first entry has been made
D. 3 years since the last entry has been made
Mark: 2
Air is removed from refrigration sytem
by (1)________ at reciver after
(2)________(3)________ Gas in
receiver. Humidificaton is process of
adding water/moiture to discharged
airof AC blower. Demumidification is
process of removing water/moisture
from air supplied from AC system. For
colecting gas in receiver you need to
close the outlet valve of receiver with
compressor running
1)
2)
3)
Which of the following conditions can lead to degradation of foam compounds?
A. Exposure to excessive heat.
B. Mixing of different grades of foam.
C. Exposure to air.
D. None of the above.
The life boat engine should be capable of starting at _______________________
A. -15 deg Celsius ambient temperature within 2 mins
B. -5 deg Celsius ambient temperature within 5 mins
C. -5 deg Celsius ambient temperature within 2 mins
D. 0 deg Celsius ambient temperature within 2 mins
Certificate of insurance or other financial security in respect of civil liability for bunker oil
pollution damage is issued under___________________
A. CLC 1969 convention
B. MARPOL convention
C. Bunker convention 2001
D. CLC 1992 convention
A straight stream of water should be used to extinguish
A. galley grease fires
B. fuel oil fires
C. burning bedding materials
D. a fire in the paint locker
Which of the following is a man overboard maneuver?
A. Neil Robertson turn
B. Williamson turn.
C. Hard port
D. Hard starboard.
The maximum capacity of an Oil fuel tank for any ship built on or after 1 st Aug. 2010 as
restricted by Marpol, Annex 1 is:
A. 600 m3
B. 1200 m3
C. 2500 m3
D. 3000 m3
Each fire pump on a MODU must have a pressure gage located
A. at the pump discharge
B. at the manifold connection
C. at each fire station discharge
D. at the pump station
Ship Security Alert System is a requirement under __________________
A. Part B of ISPS Code
B. SOLAS Chapter XI-2
C. SUA convention, 1988
D. None of the above
As per Marpol requirements, Every crude oil tanker of ______________ tones deadweight and
above delivered after 1st June 1982, shall be fitted with a cargo tank cleaning system using
_______________
A. 5000, Sea Water Washing
B. 10000, Fresh Water Washing
C. 20000, Crude Oil Washing
D. 30000, Bilge Water Washing
Which of the devices listed must be used in conjunction with the portable in-line foam
proportioner to produce foam?
A. A plain or common fire hose nozzle
B. The mechanical foam nozzle
C. Any low velocity applicator
D. An all-purpose nozzle
In refrigeration system vegetable room and meat rooms are maintained at
different
A. Different expansion valves
B. By putting solenoid valves
C. By boiling the refrigerant at different pressures
D. By using smaller evaporator
1) LONDON CONVENTION
2) HONGKONG CONVENTION
Under which IMO convention is Voyage Data Recorder- Certificate of compliance issued?
A. COLREG 1972
B. SAR 1979
C. SOLAS 1974
D. SALVAGE 1989
As required by Reg.31 of Annex 1 of Marpol the ODMCS should be provided with a
recording device for ____________ recording the discharge in litres per nautical mile and
total quantity discharged. This discharge should be kept onboard at least for a period of:
A. Intermittent, 1 year
B. Continuous, 1 year
C. Intermittent, 3 years
D. Continuous, 3 years
Changing rescuers while carrying out artificial respiration should be done
A. without losing the rhythm of respiration
B. only with the help of two other people
C. by not stopping the respiration for more than 5 minutes
D. at ten minute intervals
As per definition of MARPOL Annex-1, a product tanker is one which can carry:
A. Oils and chemicals
B. Oils other than crude oils
C. Oil product and occasionally crude oils
D. Mainly chemical products but at times refined oil products
Which of the following statements is false?
A. A ship security plan is made by the CSO
B. A ship security plan is a confidential document.
A ship security plan needs to be approved by the flag state
C.
administration
D. None of the above
In the first 24 hours after abandoning a vessel, water should be given only to personnel
who are
A. thirsty
B. sick or injured
C. wet
D. awake
Which of the following conditions can lead to degradation of foam compounds?
A. Exposure to excessive heat.
B. Mixing of different grades of foam.
C. Exposure to air.
D. None of the above.
In which of the following conditions, the IG blower fans should shut down automatically?
A. Oxygen content above 8%
B. Low water level in deck seal
C. Low water level in the scrubber tower
D. High scrubber water level
The stretcher normally used for rescue of casualties from engine room spaces, holds,
pump-rooms etc., is known as _____________________
A. Williamson stretcher
B. Neil Hobson stretcher
C. Neil Robertson stretcher
D. Stokes stretcher
As regulation 12 of Annex 1 of MARPOL, all ships of __________ gross tonnage and above
shall be provided with a sludge tank for collection of oil residues
A. 150 tonnes deadweight
B. 150 gross tonnage
C. 400 tonnes deadweight
D. 400 gross tonnage
Life buoy self-activating smoke signals should emit smoke of visible
colour for at least ______________ in calm waters.
A. 5 minutes
B. 15 minutes
C. 30 minutes
D. 60 minutes
Emergency generators should be capable of being started at ambient temperature of
______________________ deg Centigrade. If lower temperatures are expected then
___________________should be provided.
A. zero, cold starting spray
B. -5, heating arrangements
C. Zero, heating arrangements
D. -5,cold starting spray
Divisions constructed of steel which can withstand a standard fire test for 30min without
passage of flame or smoke are classified as____________________
A. B class divisions
B. A class divisions
C. A30 class divisions
D. B 30 class divisions
When applying chest compressions on an adult victim during CPR, the sternum should be
depressed about
A. 1/2 inch or less
B. 1/2 to 1 inch
C. 1 to 1 1/2 inches
D. 1 1/2 to 2 inches
As per requirements of Marpol, Annex 1, all ships delivered on or after 1 st Aug. 2010 with
an aggregate oil fuel capacity 600 m3 and above, the oil fuel can be carried in:
A. Any of the tanks without any restriction
B. Deep tanks and Double bottom tanks
C. Deep tanks in protective locations
D. Double bottom tanks not extending upto the ship???s side
Which of the following statements is true?
The installation of an IMO approved incinerator is
A.
mandatory on all ships.
The installation of an incinerator is mandatory on all ships
B.
above 400 GRT.
The installation of an incinerator is not a mandatory
C.
requirement.
The installation of incinerators is mandatory only for dry
D.
ships
2. Tests of Lifebuoy
6. Capacity of SCABA
11. Convention regarding civil & financial matters during bunker pollution refers to
33. DCP can be spoiled by whether high temp or mixing with another powders
35. How many lifebuoys can a ship carry depending on ship length
36. Depending upon ship motions i.e. rolling,pitching,yawing,heaving,surging, swaying,2 ques are coming
38. Life boat can be operated at how many degrees in how many minutes
40.EEDI is for
44.dispatch means
47. How do we maintain different temperatures in meat room & veg room(thermostatic v/v,solenoid v/v)
50. At first 20 sec after releasing CO2, what will happen..i.e.bluish skin or unconsciousness etc..
52. Under latest conventions came in Aug,2010,fuel oil tanks can be (a) deep tanks (b)double bottom
tanks (c)deep tanks with protected areas