Pic. . . . Connector seen from wire side . Battery (earth) 2L4 Batt. - Ignition on 0V Battery (earth) 2M4 Batt. - Ignition on 0V Battery (earth) 3H4 Batt. - Ignition on 0V Battery (earth) 1H1 Batt. - Ignition on 0V Alternator-Signal 3C4 Batt. - Idle, rev up 11 - 14 V Canister purge valve 2D2 Batt. - Ignition on ( 11 - 14 V ) 0V Canister purge valve 2D2 Batt. - Idle control valve activated 1028 Coolant temperature sensor 3D4 Batt. - Ignition on 0V Coolant temperature sensor 3E4 Batt. - Ignition on, 20° C 3,8 V Coolant temperature sensor 3E4 Batt. - Ignition on, 80° C 1V DIS ignition coil 3G3 Batt. - Ignition on 2 sek. Batt. + DIS ignition coil 3H3 Batt. - Ignition on 2 sek. Batt. + DIS ignition coil 3H3 Batt. - Idle 1041 DIS ignition coil 3G3 Batt. - Idle 1041 Idle step motor 1E3 Batt. - Idle 1055 Idle step motor 1D3 Batt. - Idle 1055 Idle step motor 1D2 Batt. - Idle 1055 Idle step motor 1D1 Batt. - Idle 1055 Idle step motor 1D2 1D3 Ignition off, ECU connector 48 - 62 ohm dismantled Idle step motor 1E3 1D1 Ignition off, ECU connector 48 - 62 ohm dismantled Ignition 2B4 Batt. - Ignition on 11 - 14 V Ignition 2B4 Batt. - Ignition off 0V Inductive crankshaft position 1B1 1B2 Starter rpm 2 V AC 1013 sensor Injector cyl. 1 1H2 Batt. - Ignition on ( 11 - 14 V ) 0V Injector cyl. 1 1H2 Batt. - Idle, warm 2 - 4,2 ms 1004 Injector cyl. 2 1G3 Batt. - Ignition on ( 11 - 14 V ) 0V Injector cyl. 2 1G3 Batt. - Idle, warm 2 - 4,2 ms 1004 Injector cyl. 3 1G2 Batt. - Ignition on ( 11 - 14 V ) 0V Injector cyl. 3 1G2 Batt. - Idle, warm 2 - 4,2 ms 1004 Injector cyl. 4 1H3 Batt. - Ignition on ( 11 - 14 V ) 0V Injector cyl. 4 1H3 Batt. - Idle, warm 2 - 4,2 ms 1004 Knock sensor 3C3 3B3 Idle, rev up briefly 1042 Troubleshooting-data Model: 206 1,4 Motor: KFW / Sagem S 2000
Component: From: To: Condition: Value Measured:
Pic. MAP sensor with air 1C1 Batt. - Ignition on 4,5 V temperature sensor MAP sensor with air 1C2 Batt. - Ignition on 0V temperature sensor MAP sensor with air 1C3 Batt. - Ignition on 5V temperature sensor MAP sensor with air 1C1 Batt. - Idle 1,3 V 2005 temperature sensor MAP sensor with air 3A2 Batt. - Ignition on, 20° C 3V temperature sensor MAP sensor with air 1C1 Batt. - Idle, rev up 4,4 V temperature sensor O2-sensor after cat. 3E3 Batt. - Idle, warm 0,8 ~ 0,9 V 1073 O2-sensor after cat. 3E3 Batt. - Decreasing engine rpm 0,1 - 0,4 V O2-sensor after cat. 3E3 Batt. - Increasing engine rpm 0,6 - 1 V O2-sensor with pre-heater 1A3 Batt. - Idle 0,1 ~ 1 V 1017 Relay 3F2 Batt. - Ignition off 11 - 14 V Relay 3A4 Batt. - Ignition off 0V Relay 3F2 Batt. - Starter rpm 0-1V Relay 3A4 Batt. - Starter rpm 11 - 14 V Throttle valve potentiometer 3B4 Batt. - Ignition on 0V Throttle valve potentiometer 1E1 Batt. - Ignition on 5V Throttle valve potentiometer 1A2 Batt. - Ignition on, throttle valve closed 0,6 - 0,8 V Throttle valve potentiometer 1A2 Batt. - Ignition on, throttle valve fully 3,8 - 4,6 V open Vehicle speed sensor 2G2 Batt. - Ignition on, push vehicle 1057