– A Multiplex Project Steel in Buildings CASE STUDY
! MODEL OF PRE
PLANNING FOR SUCCESS
Structural Steel Delivered:
• Speed of Construction – earlier occupancy
• Competitive Cost – reduced construction costs preliminaries and overheads • Reduced congestion in a CBD environment www.beyond2.com.au • Sustainability benefits through the ability to reuse and recycle. Latitude East – A Multiplex Project - A model of pre-planning for success. Following on from the highly acclaimed These columns were linked in an east, west Ernst and Young Building, Multiplex are direction with primary 610UB, while the completing another high profile Sydney north, south secondary beams (460UB, CBD project on the same site. 310UB) at 2.8m centres were connected with angle cleats to the main beams which Latitude East is a 24 storey complex, based took advantage of cost effective beam line on an existing 12 storey platform. This fabrication. construction features a visually stunning Over this frame a composite Bondek atrium with exposed lift and stair structures. floor was placed which include all façade The building is based on a composite requirements. structural steel frame with Bondek flooring features that have significantly reduced the The required fire rating was achieved weight of the structure and improved its through the concrete filled 600 diameter speed of construction. columns and fire rating to the primary beams only. The complexity of this construction concerned working around the existing Areas of cantilevered floors were constructed tenancy and 24 hour operational car park and by incorporating column stubs, profile cut logistics of truck movements within a very around the beam to allow a continuous restricted access CBD site. Truck loadings primary beam to pass through; the beam and movements were coordinated so was then fully welded to the stub. Carefully fabricated assembles were unloaded in the placed prefabricated reinforced cages correct sequence for cranage. This proved a from the column below gave the columns significant benefit over the truck movements continuity. which would have been associated with traditional concrete construction. The roof plant room loads were distributed to perimeter columns by suspending the In this building Lysaghts D&C were the plant room floor from node points to a prime subcontractors to Multiplex and a fabricated truss system, thus minimizing the cooperative planning process was used to number of columns to be strengthened in identify potential problems up front and to the existing structure. overcome them.
This process together with the flexibility of
the off site fabrication process delivered minimal disruption to the site, a fast Acknowledgements: program allowing follow on trades in quick succession and a clean site with a well Builder: “To achieve the tight managed construction process. Multiplex programme and Architects: To achieve the tight programme and budget Crone Partners budget constraints constraints and to take advantage of technological developments it was essential Engineering: Structural TTW and to take advantage for this forward planning and co ordination Façade Connell Mort McDonald of technological between the consultants (Architect, Crone Mechanical Waterman AHV Partners and Engineer, Taylor Thompson Prime Contractor: developments it was Whitting) the steel fabricator, mechanical Lysaghts D&C essential for this services, concrete and façade contractors to Subcontract Fabrication: be thorough and all inclusive. Allman Fabrications Steel Lift Shaft forward planning and Sebastian Engineering Beamline Structurals The structure featured 600 diameter circular Phoenix Engineering Welded Connections co ordination steel columns, reinforced. The column Erection: between the reinforcing was prefabricated to suit the Penrith Rigging column lengths and include the splice laps. Detailing: … contractors These were supplied to the steel fabricator Elmasri who inserted and tack welded them in to be thorough and position. This resulted in the column being all inclusive.” erected as complete units.