Professional Documents
Culture Documents
General Requirements
(Applicable Technical Standards, Tests etc.)
Electro-Mechanical Services
GENERAL REQUIREMENTS
(Applicable Technical Standards, Tests, etc.)
GENERAL REQUIREMENTS
(Applicable Technical Standards, Tests, etc.)
1 ELECTROMECHANICAL SERVICES
1.1 General
This part of the specification shall cover
Design
Construction
Testing and
Commissioning
Above specifications shall cover all Electromechanical Services required to form a completely
safe and reliably designed system as tendered and in accordance with the technical description of
the project.
For supply items standard designs and models from a manufacturing program of one supplier are
preferred, provided they meet the requirements of this Specification, and serve the intended
purpose.
It is not the intent to specify completely herein all the details of design and manufacturing of the
above specified equipment. It may be noted that norms, standards specified are the bare
minimum that is required. The above specified equipment shall conform in all respects to high
standards of engineering design and workmanship and should be capable of performing
continuous commercial operation within the parameters guaranteed by the supplier in a manner
acceptable to ADWEA/ADDC/AADC. ADWEA/ADDC/AADC shall have power to reject any
material if found, in their judgement, not in accordance with the specifications.
If a substantial improvement of any of the specified technical requirements, which is seen by the
Bidder/Contractor advantageous to ADWEA/ADDC/AADC, is desired to be presented in the
Bid, this may be proposed as an alternative to that, which is assumed to be in conformity with
the specified design. However, it is not mandatory that the alternative design is going to be
accepted, but shall be subject to the decision of ADWEA/ADDC/AADC upon evaluation of the
same. The difference in price shall be clearly stated in percentage/unit.
All material and equipment to be supplied under these Specifications shall be brand new and
unused and of the latest proven “state-of-the-art” technology. Prototype equipment shall not be
accepted.
1.5 Drawings
Typical drawings connected with the above specified equipment are provided under Standard
Technical Specification, Part: Drawings.
3 APPLICABLE TESTS
Details of Tests are specified in Standard Technical Specification, Part:
S-AAA-GEN-GDF - General Requirements – General Conditions