Professional Documents
Culture Documents
SECTION A
NAME:
Muhammad Sufyan Khan (CIIT/FA20-CHE-039/LHR)
Taha Mustafa (CIIT/FA20-CHE-083/LHR)
Syed Taha Hussain (CIIT/FA20-CHE-052/LHR)
Mujtaba Hassan (CIIT/FA20-CHE-062/LHR)
Mahdi (CIIT/FA20-CHE-70/LHR)
DEPARTMENT:
Chemical Engineering
SUBJECT:
Engineering Drawing
ASSIGNMENT TOPIC:
Lab Rubric 2
SUBMITTED TO:
Sir Waleed Siddiqui
FRONT VIEW:
Type limits in command menu and set value to 297,290.
Change the units to millimeters from inches and precision to 0 by clicking
format then unit and press ok.
To set the paper type zoom then enter and type a then enter in Command
bar.
Then choose line and add command (0,100),(-30,0),(0,50),(360,0),(0,-50),(-
30,0),(0,-100).
Then Draw a concentrated circle of radius 260 which touches mid of
horizontal line 360.
Now click off set option and give distance 150 for small arc and for big arc
give 130 distance.
Now click off set option again and give distance 150 and 130 for anothers
bigger arcs.
Now from Small arc on right side choose line add commands from its end
(@100,0),(0,30),(50,0),(0,-360),(-50,0),(0,30),(-100,0).
Now use a Hatch command and shade the curve area.
Measure the dimensions.
TOP VIEW:
First of all take starting point (0,0)
Now choose line and draw a square box add commands (@360,0),(0,360),(-
360,0),(0,-360).
Now choose fillet command and fillet the corner of diagram by choosing
radius 20.
Now draw 2 axis line vertical and horizontal by choosing offset command
and give distance 180.
Now again choose offset command choose vertical line of square box give
distance 50.
Now Draw 4 circles of diameter 60 and 30 at the corner of diagram.
Now draw a circles from mid point of 2 axes line of diameter 210 and 190.
Now again draw 2 lines from end of diagram at right side add commands
(@150,0)
From one line as a starting point add commands (@0,30),(@50,0),(@0,-
360),(@-50,0),(@0,30) and meet with other point.
Now choose a fillet command give radius 10 and filltet both lines.
Right view:
First of all take starting point (0,0)
Now choose line and draw a square box add commands (@360,0),(0,360),(-
360,0),(0,-360).
Now choose fillet command and fillet the corner of diagram by choosing
radius 20.
Now draw 2 axis line vertical and horizontal by choosing offset command
and give distance 180.
Now again choose offset command choose vertical line of square box give
distance 50.
Now Draw 4 circles of diameter 60 and 30 at the corner of diagram.
Now draw a circles from mid point of 2 axes line of diameter 210 and 190.
Now again draw 2 lines from end of diagram at right side add commands
(@150,0)
From one line as a starting point add commands (@-30,0),(@0,50),
(@360,0),(@0,-50),(@-30,0) and meet with other point.
Now choose a fillet command give radius 10 and filltet both lines.
Now Choose Hatch command and shade the area.
Measure the dimensions.