Professional Documents
Culture Documents
Type of Job being analyzed: INSTALLATION AND TESTING OF WELDING SOCKETS AND POWER OUTLETS
JHA Members: HSE Department, Construction Manager
Department/Section originating JHA
JOB Performers: Supervisor, Electricians, Riggers, Helpers
Normal approvals: Name Signature DATE GENERAL JOB REQUIREMENTS
JHA By: George.K.Thomas COMMON PPE
Avaneesh Chaudhary 9/8/2007
GENERAL JOB REQUIREMENTS
Additional Approvals (Determined by JOB Supervisor in correlation with CTJV EHSS Manager) 1 CTJV EHSS Inducted workforce
Name Signature Date 2 Dodsal HSE Inducted
3 Daily TBT
4 Adequate supervision
Discipline Superintendent (CTJV) 5 Third Party certified, colour coded lifting
EHSS Representative (CTJV) equipments and lifting tools & tackles.
EHSS Representative (Company) 6 Valid Qatari Licenses for drivers & operators
CTJV I.H. 7 Third Party certified, competent operators,
Other (List Below) electricians, riggers.
PPE
NOMEX Coveralls, Safety shoes, Helmets
Notes: EHSS sign when required for hazardous Safety Goggles , Appropriate Hand gloves
Work details as required by CTJV PTW. 8 S.T.A.R.T CARD
APPROVAL REQUIRED FOR HAZARDOUS WORK DETAILED IN THE CTJV WORK PERMIT PROCEDURE 9 Heat Stress Management
CHANGING CONDITIONS & EMERGENCY PROCEDURES Stop Work, Switch Off Equipment, Supervisor Directs Personnel to Nearest and Safest
Muster point Considering Wind direction. Supervisor accounts for all Workers.
Missing persons are reported to CTJV EHSS Dept. When all clear is given check with CTJV EHSS before resuming to work.
EMERGENCY TELEPHONE NO: Ras Gas - 473 8999
Note: If any of the tasks involves biological, physical or chemical hazards, then CTJV Industrial Hygienist must also approve the work
Use additional sheets as necessary
Details on safety (PPE, Hazards etc) and environmental requirements can be found in CTJV and Ras Gas Safety and Environmental procedure.
Unwanted disturbance/personnel
Ensure area is barricaded and no unwanted personnel movement
movement in the work area
Always secure the area of barricading and correct safety signage
Poor barricading and no safety
5.0 Area Preparation & Barricading 5.1 5.1.1 as per activities Site supervisor
Signage
Print the name and contact number of in-charge electrician are in
No contact person in case of
place.
electrical trouble.
DOD-MST-E-011 INSTALLATION AND TESTING OF WELDING SOCKETS AND POWER OUTLETS NO WATER - NO WORK Page 2 of 3
Doc. #: DOD-MST-E-011 INSTALLATION AND TESTING OF WELDING SOCKETS AND POWER OUTLETS
SEQUENCE OF BASIC
POTENTIAL HAZARDS HAZARDS CONTROL RESPONSIBLE PARTY
ACTIVITY STEPS
DOD-MST-E-011 INSTALLATION AND TESTING OF WELDING SOCKETS AND POWER OUTLETS NO WATER - NO WORK Page 3 of 3