This document contains 4 questions about calculating frequencies and timing periods in different oscillator circuits. Question 1 asks to calculate component values to generate a 5.2kHz sinusoidal waveform using a Wien Bridge oscillator. Question 2 asks for the frequency of an op-amp multivibrator circuit given component values. Question 3 asks to calculate the range of output frequencies for a variable op-amp multivibrator. Question 4 asks to find the width of an output pulse for an op-amp monostable circuit given component values and a 10ms input pulse.
This document contains 4 questions about calculating frequencies and timing periods in different oscillator circuits. Question 1 asks to calculate component values to generate a 5.2kHz sinusoidal waveform using a Wien Bridge oscillator. Question 2 asks for the frequency of an op-amp multivibrator circuit given component values. Question 3 asks to calculate the range of output frequencies for a variable op-amp multivibrator. Question 4 asks to find the width of an output pulse for an op-amp monostable circuit given component values and a 10ms input pulse.
This document contains 4 questions about calculating frequencies and timing periods in different oscillator circuits. Question 1 asks to calculate component values to generate a 5.2kHz sinusoidal waveform using a Wien Bridge oscillator. Question 2 asks for the frequency of an op-amp multivibrator circuit given component values. Question 3 asks to calculate the range of output frequencies for a variable op-amp multivibrator. Question 4 asks to find the width of an output pulse for an op-amp monostable circuit given component values and a 10ms input pulse.
A Wien Bridge Oscillator circuit is required to generate a sinusoidal
waveform of 5,200 Hertz (5.2kHz). Calculate the values of the frequency determining resistors R1 and R2 and the two capacitors C1 and C2 to produce the required frequency. Q2. An op-amp multivibrator circuit is constructed using the following components. R1 = 30kΩ, R2 = 35kΩ, R = 50kΩ and C = 0.01uF. Calculate the frequency of oscillation. Q3. The fig shows a Variable Op-amp Multivibrator. By adjusting the central potentiometer between β1 and β2 the output frequency will change by the following amounts. Find the range of out frequencies. Q4. In the circuit shown with R1 = 30kΩ, R2 = 30kΩ, R = 150kΩ and C = 1.0uF. If the op-amp monostable is supplied from a ±12V supply and the timing period is initiated with a 10ms pulse, find the width of the output pulse.