Professional Documents
Culture Documents
Bubble Test Direct Pressure
Bubble Test Direct Pressure
Authorized By:
____________________________
Senior Inspector
Methanex Corporation
Medicine Hat, AB
Copy: 01
Revision Date: January 7, 2000
\\mxcmhtnt1\inetpub\wwwroot\procedures\maintenance\inspection\nde\lt-01.doc
TABLE OF CONTENTS
BUBBLE TEST DIRECT PRESSURE TECHNIQUE
2. Equipment:
3. Note: Inert gas may be used. Safety aspects of oxygen deficient atmospheres should be
considered.
5. Surface cleanliness: surface must be clean and free of paint, primer, weld, slag, etc.
6. Method or Technique:
• Apply bubble solution with spray brush or drip / pouring. Do not agitate in such a manner as
to create bubble as a result of application.
• The part being tested shall be between 40ºF and 125ºF during the test.
8. Post cleaning may be required where solution may impede future operations, i.e. painting, etc. or
the serviceability of the equipment.
9. Where repairs are required the equipment will be depressurized, repaired in accordance with the
applicable code section and the test repeated.