Professional Documents
Culture Documents
®
bmSOLUTION Series for Total Water Management
ISO 9001:2008 Certified
GHS Classification:
Health Environmental Physical
GHS Label:
Pictograms
Signal word:
Warning
Page 1 of 5 M3800ME/0715/00
bmSOLUTION® 3800 ME
®
bmSOLUTION Series for Total Water Management
ISO 9001:2008 Certified
SKIN CONTACT:
Remove contaminated clothing. Wash off affected area immediately with plenty of water. If skin irritation
persists, obtain medical attention.
EYE CONTACT:
Immediately gently irrigate with clean water for at least 15 minutes. Move eyeball and keep eyelids wide open
and apart whilst irrigating. Obtain medical attention.
INGESTION:
Rinse mouth immediately and repeatedly with water. Do not induce vomiting without medical advice. Obtain
medical attention.
EXTINGUISHING MEDIA:
In case of fire, use Water spray, foam, dry powder, carbon dioxide. Water mist may be used to cool closed
containers. Evacuate personnel to safe areas.
PERSONAL PRECAUTIONS:
Do not breathe vapour. Avoid contact with skin and eyes. Take off immediately all contaminated clothing. Use
personal protective equipment recommended in Section 8.
ENVIRONMENTAL PRECAUTIONS:
Do not discharge into drains or the environment, dispose to an authorized waste collection point. Do not allow
Page 2 of 5 M3800ME/0715/00
bmSOLUTION® 3800 ME
®
bmSOLUTION Series for Total Water Management
ISO 9001:2008 Certified
material to contaminate ground water system.
PHILIPPINES: Not established for the product. However the following component has been assigned an exposure
standard under the Occupational Health and Safety Standards, as amended 1992:
3
Di-Sodium tetraborate Pentahydrate TWA 1 mg/m
ENGINEERING MEASURES
General ventilation is recommended.
RESPIRATORY PROTECTION:
Respiratory protection not normally needed.
HAND PROTECTION:
PVC gloves, Rubber gloves, Neoprene gloves, Nitrile gloves.
SKIN PROTECTION:
Apron and boots.
EYE PROTECTION:
Chemical splash goggles, face shield.
HYGIENE RECOMMENDATIONS:
Keep an eye wash fountain available. Keep a safety shower available. If clothing is contaminated, remove
clothing and thoroughly wash the affected area. Launder contaminated clothing before reuse.
Page 3 of 5 M3800ME/0715/00
bmSOLUTION® 3800 ME
®
bmSOLUTION Series for Total Water Management
ISO 9001:2008 Certified
Section 10 : Stability and Reactivity
Acute Effects:
Eyes : No known significant effects or critical hazards.
Skin : No known significant effects or critical hazards.
Inhalation : No known significant effects or critical hazards.
Ingestion : May be harmful is swallowed.
Eco-toxicity : No specific data is available on this product. However, for the chemical
components which make up this product, there may be specific data
available and in the public domain. Consult the data available for each
individual raw material component.
Environmental Fate : No studies have been conducted for this specific product.
Environmental Degradation : Not tested for this product blend.
Soil Absorption/Mobility : Not tested for this product blend.
Land Transport:
Proper Shipping Name: Product is not regulated during transportation
Air Transport:
Proper Shipping Name: Product is not regulated during transportation
Page 4 of 5 M3800ME/0715/00
bmSOLUTION® 3800 ME
®
bmSOLUTION Series for Total Water Management
ISO 9001:2008 Certified
State Regulations: As a product blend, the materials are generally not listed. Check with your local state
regulatory board for more detailed information regarding the specific components of this product.
Disclaimer:
DISCLAIMER OF LIABILITY
As the conditions or methods of use are beyond our control, we do not assume any responsibility
and expressly disclaim any liability for any use of this material. Information contained herein is
believed to be true and accurate but all statements or suggestions are made without warranty,
expressed or implied, regarding accuracy of the information, the hazards connected with the use of
the material or the results to be obtained from the use thereof. Compliance with all applicable
federal, state and local laws and regulations remains the responsibility of the user.
Page 5 of 5 M3800ME/0715/00