Professional Documents
Culture Documents
STRIP SYSTEM
DESCRIPTION TYPICAL DRY FIBER PROPERTIES
The Tyfo® UC Laminate Strips are unidirectional pull-formed, Material properties are based on standard laboratory conditons
epoxy-carbon composite laminates. The rigid laminates are (23°C, 50% relative humidity.)
premanufactured resulting in high strength, high modulus
PROPERTY TYPICAL TEST VALUE
composites.
COVERAGE
30 sq. ft per unit at a thickness of 1/16” when using Tyfo® TC.
50 sq. ft per unit at a thickness of 1/16” when using thickened
Tyfo® S (field made). Coverage is highly dependent on substrate
condition and environment. Refer to the appropriate epoxy data
sheet for more information.
SHELF LIFE
Epoxy - two years in original, unopened and properly stored
containers
UC Laminates - 10 years in proper storage conditions
STORAGE CONDITIONS
Store epoxy at 60°F to 100°F (15°C to 38°C). Resin is susceptible
to crystallization at temperatures below 50°F. If crystallized,
epoxy must be reheated until clear. Store fabric rolls flat,
not on ends, and at temperatures below 100°F (38°C).
Avoid moisture and water contamination
Statement of Responsibility: The technical information and application advice in this publication is based on the present state of our best scientific and practical knowledge. As the nature of the
information herein is general, no assumption can be made as to the product’s suitability for a particular use or application, and no warranty as to its accuracy, reliability or completeness, either
expressed or implied, is given other than those required by State legislation. The owner, his representative or the contractor is responsible for checking the suitability of products for their intended
use. Field service, where provided, does not constitute supervisory responsibility. Suggestions made by the Fyfe Co., either verbally or in writing, may be followed, modified or rejected by the owner,
engineer or contractor since they, and not the Fyfe Co., are responsible for carrying out procedure appropriate to a specific application.
TYFO® UC LAMINATE
STRIP SYSTEM
Fyfe Co. LLC Fyfe Asia Pte Ltd Fyfe Europe/Insituform Linings Ltd
4995 Murphy Canyon Rd., Suite 110, 6 Clementi Loop, #02-20 4-8 Brunel Close
San Diego, CA 92123 (Level 4), Singapore 129814 Park Farm Industrial Estate
Tel: 858.642.0694 Fax: 858.444.2982 Tel: +65.6898.5248 Fax: +65.6898.5181 Wellingborough, Northamptonshire NN8 6QX
Email: info@aegion.com Email: fyfeasia@aegion.com Tel: +44 1933 678266
Web: www.fyfeco.com Web: www.fyfeasia.com Web: www.fyfeeurope.com
TyfoUC 04/20 Aegion®, Fyfe® and Tyfo® are the registered trademarks of Aegion Corporation and its affiliates. © Aegion Corporation