Professional Documents
Culture Documents
Fault tracing 6
Check the bypass valve and change it if necessary.
The fuel gauge shows full travel although no alarm
has been activated. 7
Check the feed pump.
Possible reason
Open circuit in battery negative.
Suitable action
FMI 3: Abnormally high voltage or short
circuit to higher voltage has been
Check cables between the sensor and engine control
unit. detected.
Fault code conditions
FMI 1: Too low fuel pressure
The voltage on pin 16 in the engine control unit ex-
ceeds 4.95 Volt.
Fault code conditions
Fuel pressure depends on engine speed. Possible reason
D9 ● Short circuited signal cable to battery voltage or
Engine speed 600 800 1000 1200 1400 rpm. 5 V voltage.
Alarm 100 100 150 200 250 kPa ● Fault in sensor.
(1.00) (1.00) (1.50) (2.00) (2.50 Bar)
(14.5) (14.5) (21.8) (29.0) (36.3 psi)
Suitable action
Engine speed 1600 1800 2000 2200 2300 r/min.
1
Alarm 250 250 250 250 250 kPa Check cables between the sensor and engine control
(2.50) (2.50) (2.50) (2.50) (2.50 Bar) unit.
(36.3) (36.3) (36.3) (36.3) (36.3 psi)
2
D12-800 Check sensor.
Engine speed 500 1800 2300 rpm.
Alarm 50 200 200 kPa
(0.50) (0.20) (0.20 Bar)
(7.25) (29.0) (29.0 psi)
37