This document provides instructions for checking and adjusting the gap between the front engine mount support props on certain engine models. The gap should be 2.5mm for new mounts and may be greater for used mounts, but must be the same on both sides. The procedure involves using a feeler gauge to measure the gap, loosening the mount nuts if needed, adjusting the support position with the gauge, and retightening the nuts to the specified torque of 90 Nm. Commercially available measuring instruments like feeler gauges can be used.
This document provides instructions for checking and adjusting the gap between the front engine mount support props on certain engine models. The gap should be 2.5mm for new mounts and may be greater for used mounts, but must be the same on both sides. The procedure involves using a feeler gauge to measure the gap, loosening the mount nuts if needed, adjusting the support position with the gauge, and retightening the nuts to the specified torque of 90 Nm. Commercially available measuring instruments like feeler gauges can be used.
This document provides instructions for checking and adjusting the gap between the front engine mount support props on certain engine models. The gap should be 2.5mm for new mounts and may be greater for used mounts, but must be the same on both sides. The procedure involves using a feeler gauge to measure the gap, loosening the mount nuts if needed, adjusting the support position with the gauge, and retightening the nuts to the specified torque of 90 Nm. Commercially available measuring instruments like feeler gauges can be used.