Professional Documents
Culture Documents
FS-N Series Setting Guide: Basic
FS-N Series Setting Guide: Basic
Basic
Sensitivity setting Setting value Current value Fine sensitivity adjustment Mode/Output*2 Preset function
Power select
switch *1
*1 This is a channel switch on 2-output types. This is not equipped with the 0-line type.
*2 Press and hold the [MODE] button to make advanced setting changes.
Calibration Method
Complete
* When the difference is small., "----" is displayed.
FS-N-1
Advanced
Other Calibration Methods
FS-N
Work-Preset
The current value is corrected to 0.0. Arbitrary two points can be corrected to
"100.0" and "0.0" by using this function in combination with the Preset function.
LV-N
Workpiece
Green "PST"
Common to
Thrubeam and Reflective Models
Press the [SET] button while 2 Press and set any numerical value (up to 4
pressing the [MODE] button. digits).
* To disable this function, press [SET] while
pressing [MODE].
3 Press [MODE].
Output Switch "Loc" is displayed, and button
operation is disabled. Then, the
current light intensity is displayed.
Either light-ON (L-on) mode or dark-ON (D-on) mode can be
selected.
2 Use to switch the output (L-on/D-on), then 2 Press to specify a password, and press
press the [MODE] button again. [MODE].
The output change completes, and the display returns to the "unL" is displayed, and button
current value. operation is enabled.
FS-N-3
Advanced
Detailed Settings
Normal sensitivity setting method Disable the saturation of the Preset function
Percentage Calibration*1 Settings complete
Zero-shift calibration Go to system setup mode
MODE
*1 You can press the button to set between the range of -99P to 99P.
System Settings LR-Z