Professional Documents
Culture Documents
DX80R
July, 2009
Overseas Product Support Team
Text No. HYD0062
Control valve
2
Control valve
1. Inlet block
2. Boom block
3. Bucket block
4. Arm block
5. Dozer block
6. Option block
7. Travel(L) block
8. Travel(R) block
9. Boom swing block
10. Inlet-2 block
11. Swing block
12. Outlet block
3
Control valve
4
Control valve
1. housing
2. Spool
3. Check valve
4. Pressure Compensator
5. Secondary Vavle
6. Plug
5
Control valve
LS
Spool
Flushing valve
compensator
6
Control valve
• LS System(1)
△P = P1- P2
Q= kA√△P or △P = k(Q/A)²
Control valve
• LS System(2)
Control valve
A1 A2
Control valve
• Flow regulator
1. Function :
-When System pressure drops down,
LS pressure doesn’t drop
immediately
-> capacity of hose
-> compensator is closed
- System pressure is higher than load
pressure
-> abnormal engine load
Flow regulator decompresses LS line
2. Remarks
Flow regulator is orifice valve installed
strainer on front of the valve
Control valve
1. Function :
- Available oil for anti-cavitation valves
- Minimum cooling function
- Safety valve.
- Ready to move each actuator.
2. Remarks
- The setting pressure would be
adjusted by inside shim.
Control valve
• Flushing Valve (2)
P LS
1.Function :
- Restrict the max system pressure
2.Remarks
- The primary valve is the same as a
secondary valve
- Setting Pressure
Primary valve : 340bar
Secondary valve :310bar
Control valve
1.Function :
- Restrict the max LS pressure
2.Remarks
- The setting pressure of LS relief
valve is 280bar
Control valve
Pump – 15 bar
0
bar
15
bar
Spool : Meter in
15
bar
Compenasator
Orifice
P
Pump
Control valve
Stalled actuator
pump pressure = max pressure
P pump
15 bar
~ 0 bar
15 bar Spool
meter in
Compensator
orifice
P pump
Control valve
• Flow System(12)
Control valve
Actuation
Control valve
Actuation Actuation
Control valve
A Type
B Type
Marking
B Type Arm, Bucket, Dozzer, Travel, Option, B/Swing,Swing The marking of the spool must be B port