Professional Documents
Culture Documents
Clamps
Clamps
Slurry Hose Systems
Characteristics
Clamping is done every 1000 to 1500 mm in a
straight line on both vertical and horizontal layouts.
In curved sections, tighter clamping is recom-
mended.
PTD06-07EN 1/2017 © Metso Corporation
Slurry Hose Systems
Clamps
Technical description
Clamps are made of galvanized steel and
correspond to SSG 7075 standard.
Installation
Clamps are available in sizes matching the size of
hoses and pipes, see table below. The following
spacing between each clamp is recommended:
Clamps
Hose / Pipe ID Clamp Width Total Weight Screw Dim. Pipe ID Length
Part no.
mm inch mm inch kg lbs Metric inch mm inch mm inch
SH-596551 51 2 40 1.6 0.5 1.1 M10x40 3/8 x 1.6” 51 2 250 10
SH-596577 76 3 50 2 1.4 3.1 M10x40 3/8 x 1.6” 76 3 350 14
SH-575043 102 4 50 2 1.6 3.5 M16x60 5/8 x 2.4” 102 4 450 18
SH-575050 127 5 50 2 1.8 4 M16x60 5/8 x 2.4” 127 5 500 20
SH-575068 152 6 50 2 2 4.4 M16x80 5/8 x 2.4” 152 6 650 26
SH-575076 204 8 60 2.4 4.2 9.3 M20x80 3/4 x 3.2” 204 8 800 32
SH-575084 254 10 60 2.4 4.9 10.8 M20x80 3/4 x 3.2” 254 10 1000 39
SH-575092 305 12 60 2.4 5.5 12.1 M20x80 3/4 x 3.2” 305 12 1200 47
SH-602904 355 14 70 2.8 9.3 20.5 M20x80 3/4 x 3.2” 355 14 1300 51
SH-602896 405 16 70 2.8 10.1 22.3 M20x80 3/4 x 3.2” 405 16 1500 59
SH-602888 457 18 70 2.8 11 24.3 M20x80 3/4 x 3.2” 457 18 1600 63
SH-602870 508 20 100 4 20.2 44.5 M24x100 1 x 4” 508 20 2 x 1800 2 x 71
SH-602862 610 24 100 4 23.4 51.6 M24x100 1 x 4” 610 24 2 x 2100 2 x 83
PTD06-07EN 1/2017 © Metso Corporation
Metso Corporation
Töölönlahdenkatu 2, FI-00100 Helsinki, Finland
Email: flowcontrol@metso.com, www. metso.com/SHS
Product names in this article are all either registered trademarks or trademarks of Metso Corporation and its subsidiaries.