Professional Documents
Culture Documents
1.
(a) For the voltage-divider configuration shown in the Figure,
determine the dc bias voltage VCE and the current Ic. Use
VBE=0.7V. (3)
2.
(a) Perform DC analysis on the network shown below, to calculate:
(i) , (ii) (iii) VDS (3)
2
3.
(a) For the following Zener regulator circuit, determine the
minimum and maximum values of load resistor RL that would
maintain the regulated voltage at 10V. (3)
VZ =10V
(2)
4.
(a) Calculate the frequency of oscillation (in KHz) of the IC-555
timer circuit.(Given: RA=2.2KΩ, RB=4.7KΩ and C=0.055 F)
(2)
3
(b) Explain the working of Monostable operation of IC-555 Timer
with the internal circuit diagram. Also deduce the relationship for
the Time period of the output waveform. (4)
(c) Define Input offset voltage and CMRR of an op-amp. (2)
5.
(a) Draw the circuit of class A series-fed amplifier. Calculate the
output power and efficiency of this amplifier for an input voltage
that results in based current of 10mA peak. (Given: Vcc=20V,
RB=1KΩ, RC=20Ω , β=25, VBE=0.7V). (4)
(b) Draw the circuit of differentiator using Operational Amplifier
and write the expression for output. (2)
(c) For the op-amp circuit shown below, compute the value of
output voltage. (2)