Professional Documents
Culture Documents
commands.
Objective: Creating intermediate complex level sketches and features commands.
Marks Obtained: _______
Lab Module No. 3
Course teacher/Lab Instructor: Dr Wasim Ahmad
Student Name: __________________________
Registration no.__________________________
1|Page
To draw Intermediate complex level sketches using sketch and features
2|Page
Step 2: Draw the given sketches using line commands
3|Page
Step 3: Further draw the given sketch using center point arc commands and finally remove
unnecessary lines using Power Trim Command
4|Page
Step 4: Use the Extruded Boss/Base command to draw the 3D shape. (Note the Extruded Boss
height is 1.5Inch)
Step 5: Select the edge of the shape to develop the second sketch.
5|Page
Step 6: Select the edge of the shape to develop the second sketch. The second sketch will be
rectangle with the following dimension.
6|Page
Step 7: Employ the extruded cut command to remove the material as shown in figure.
7|Page
Step 8: Select the given edge of the shape to develop the third sketch.
8|Page
Step 10: Employ the extruded cut command to remove the material as shown in figure.
9|Page
Draw the second sketch yourself
10 | P a g e