EXAMINATION ELECTROMOTIVE FORCE BATCH 1 RME QUICK VIEW Q#1 Two 500 watt lamps connected in series across a 120- volts source draws 3 amps, the total wattage consume is ____. A. 1000 W B. 500 W C. 360 W D. 200 W RME QUICK VIEW Q#2 A 4 Ω, a 6 Ω, a 10 Ω and a 15 Ω are connected in parallel. Which resistor will consume the most power? A. 4 Ω B. 6 Ω C. 10 Ω D. 15 Ω RME QUICK VIEW Q#3 If a light bulb rated 100 W at 120 V is connected across a 240 V source the wattage would be ____. A. 100 W B. 200 W C. 300 W D. 400 W RME QUICK VIEW Q#4 A coil having an inductance of 20mH is connected into a 110 V, 50 Hz source. Calculate the inductive reactance A. 6.283 Ω B. 8.459 Ω C. 2.464 Ω D. 3.333 Ω RME QUICK VIEW Q#5 An inductive circuit takes 10 A and 1920 W when connected to a 240 V , 60 Hz source. Determine the operating power factor of the circuit. A. 0.6 B. 0.7 C. 0.80 D. 0.9 RME QUICK VIEW Q#6 To provide for small appliance in a dwelling unit, the feeder should be computed at _____. (RME OCTOBER 1994) A. 2400 VA B. 1500 VA C. 3000 VA D. 3600 VA RME QUICK VIEW Q#7 Determine the minimum small appliance and laundry loads requires for a dwelling units. A. 4000 VA B. 3000 VA C. 1500 VA D. 2000 VA RME QUICK VIEW Q#8 Branch circuit conductors supplying a single motor shall have an ampacity in terms of the full load current of NOT less than (RME APRIL 1994) A. 100% B. 125% C. 130% D. 115% RME QUICK VIEW Q#9 A 138 microfarad capacitor is connected across a 230 V, 50 Hz source. Estimate the current drawn. A. 8 A B. 10 A C. 12 A D. 14 A RME QUICK VIEW Q#10 At what frequency will the inductive reactance of a 100 mH inductor be equal to 15.708 Ω? A. 25 Hz B. 50 Hz C. 60 Hz D. 70 Hz