Professional Documents
Culture Documents
<A>3. A qualifying term indicating that the circuit breaker can be set
to trip at various values of current and/or time within a
predetermined range is called____.
(A)adjustable (B) instantaneous trip
(C) setting (D) inverse time
<B>7. The resistance of a 3.6 kw heater when operated from a 120 volt circuit
is ____ ohms.
(a) 3 (b)4 (c) 30 (d) 120
<D>12. Metal cabinets used for lighting circuits are grounded in order
to ____.
I. eliminate electrolysis
II. simplify wiring
III. limit the voltage to ground
IV. facilitate overcurrent device operation
(a) I only (b) I and II only
(c) III only (d) III and IV only
<C>22. Boxes used for ceiling outlets in all types of concealed wiring
installed in buildings of all types of construction are____.
(a)square (b) oblong (c) octagonal (d) devices
<C>24.You have 120 volts at the panel and 115 volts at the load. What is
the percentage of voltage drop?
(a) 5 % (b)4.35% (c) 4.17% (d) 3%
<B>26. The _____ is the sevice conductors between the terminal of the
service equipment and a point usually outside the building, clear of
building walls, where joined by tap or splice to the service drop.
I. service drop
II. service entrance conductors, overhead system
III. service equipment
(a) I only (b) II only (c) III only (d) I,II and III
<B>27.If the circit voltage is increased, all else remains the same,
only the _____ will change.
(a) resistance (b) current (c) ampacity (d) conductivity
<A>28. To ensure proper adhesion between wire, solder and a lug, the
temperature of the ____must be above the melting point when they are
brought togeter in soldering.
I. wire II. solder III. lug
(a) I,II and III (b) I and II only
(c) II and IIIONLY (D) II only
<A>35. When calculating the cubic inch capacity required for a box, 3
equipment grounding conductors are counted as ____ conductor/s.
(a) 1 (b) 2 (c) 3 (d) not counted
<D>54. An appliance that is not easily moved from one place to another in
normal use is a ______appliance.
(a) fastened in place (b) dwelling-unit
(c) fixed (d) stationary
<D>73.It is generally not good practice to supply lights and motors from
the same circuit because ____.
(a) lamps for satisfactory service must operate within closer
voltage limits than motors
(b) overloads and short circuits are more common on motor circuits
(c) when motors are started, the large starting current causes a
voltage drop on the circuit and the lights will blink or burn dim
(d) all of these
<C>75. The overhead service conductors from the last pole or other
aerial support to and including the splices, if any, connecting to the
service entrance conductors at the building or other structure
is the ____.
(a) service load (b) service lateral
(c) service drop (d) service supply
<D>79. To calculate the power used by an appliance (not motor driven) one
needs to know____.
I. voltage and current
II. current and resistance
III. voltage and resistance
(a) I only (b) II only (c)III only (d) I,II or III
<B>95. In a three-phase, 4 wire wye system having 277v for lighting, the
three-phase motors would be operating on a voltage of_____volts.
(A) 208 (B) 480 (C) 240 (D) 190
<C>96. Four heater coils with a given voltage will consume the most
power when connected_____.
(A) all in series
(B) two in parallel
(C) all in parallel
(D) two parallel pair in series