Professional Documents
Culture Documents
MULTIPLE CHOICE
1. A device that de-energizes a circuit or a portion of a circuit within an established
time frame when a current to ground exceeds the values determined for a class A
device is which of the following: September 2022 RME BE
A. Fuse C. Circuit breaker
B. Voltage regulator switch D. Ground Fault Interrupter
2. The definition of a pool includes wading, swimming and therapeutic pools, and the term
fountain includes which of the following: September 2022 RME BE
I. Reflection pools III. Display pools
II. Drinking fountain IV. All of the above
A. II C. All of the above
B. I,III,IV D. IV only
3. A bare conductor is one with:
A. Several layers of thermoplastic insulation
B. Only one layer of insulation
C. A covering that is not recognized by the PEC as electrical insulation
D. No covering or insulation whatsoever
4. Which of the following anchors may not be used to secure electrical equipment to
masonry walls?
5. Service entrance using copper conductors shall have sufficient capacity and shall NOT
be smaller than_____.
a. 5.5 mm2 b. 3.5 mm2 c. 14.0 mm2 d. 8.0 mm2
6. A motor enclosure designed and constructed to contain sparks of flashes that may
ignite surrounding gas or vapour is called ____. September 2022 RME BE
A. Encapsulated C. non-ventilated
B. explosion proof D. water cooled
7. Something constructed so that moisture will not enter the enclosure under specific
test conditions is called_______.
a. Watertight b. moisture proof c. waterproof d. rainproof
8. Two resistors R2-20Ω and R3-20Ω are connected in parallel, but resistor R1-5Ω is in
series with both the battery and the parallel combination of R2 and R3. What is the
total resistance of R2 and R3?
a. 40Ω c. 20Ω
b. 10Ω d. 30Ω
9. If the total combined resistance of R2 and R3 is 10Ω, what is the total resistance of
the entire circuit if R1-5Ω?
a. 15Ω c. 45Ω
b. 20Ω d. 5Ω
10. An incandescent lamp has a resistance of 104 ohms when 2 amperes of current flow. What
is the voltage?
a. 240 volts c. 120 volts
b. 208 volts d. 12 volts
11. What is the resistance of a parallel circuit resistors 30 ohms and 50 ohms?
a. 22.50 ohms c. 6.85 ohms
b. 18.75 ohms d. 10.55 ohms
12. What is the total resistance of the series circuit with four Christmas lights
connected, each of which has a resistance of 3 ohms?
a. 2 ohms c. 6 ohms
b. 4 ohms d. 12 ohms
13. What is the minimum size THW cooper conductor that may be used on a 30-ampere branch
circuit?
a. No. 14 AWG c. No. 10 AWG
b. No. 12 AWG d. No. 8 AWG
14. The PEC allows wall-switch controlled receptacles in dwelling units in liue of
lighting outlets in all habitable rooms except:
a. Basement and attic c. bedrooms
b. Living room and family rooms d. kitchen and bath
15. Insulated conductors of No. 6 or smaller intended for use as grounded conductors in a
circuit must be either if the following colors:( Sept. 7, 2021 RME)
a. Blue or black
b. Red or black
c. White, gray or have three continuous white stripes on other than green insulation
d. Orange or yellow
REGISTERED MASTER ELECTRICIAN Licensure Examination
April 2023 1:00 PM – 5:00 PM
***END***