You are on page 1of 2

UENR2155-01

October 2020 Harness And Wire Electrical Schematic Symbols


Symbols

Pressure Temperature Level Flow Circuit Breaker


Component Location Symbol Symbol Symbol Symbol Symbol
Schematic
Component
Location Symbols and Definitions
Breaker - Object Detection E-4
Fuse: A component in an electrical circuit that will open the circuit if too much current flows
Camera - Rear C-4
through it.
Converter - 24V/12V D-1
Display C-1 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Ground - Cab E-3 circle indicates that the component has screw terminals and a wire can be disconnected from it.
Radar - Long Range Side (Rear) E-7
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
Relay - Main Power D-5
No circle indicates that the wire cannot be disconnected from the component.
Resistor - Terminating CAN 1A D-1
Resistor - Terminating CAN 1B E-7 Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

988G Wheel Loader


Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Connector Location contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Schematic
Connector Number

CAT Detect Object Detection


Location ® Sender: A component that is used with a temperature or pressure gauge. The sender
CONN 1 E-3 measures the temperature or pressure. Its resistance changes to give an indication to
CONN 2 D-3
T
the gauge of the temperature or pressure.
CONN 3 C-3

The connectors shown in this chart are for harness


Electrical System Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
to harness connectors. Connectors that join a electromagnet can open or close the switch part of the relay.
BNH1-UP
harness to a component are generally located at or 2TW1-UP
near the component. See the Component Location Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
Chart.
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is


activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols


Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
L-C12
111-7898 3E-5179 3E-5179
Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
2
5A
Plug Receptacle Component
Pin or Socket Number Fuse (5 Amps) 9X-1123 Part Number

1 Deutsch connector: Typical representation


325-AG135 PK-14
of a Deutsch connector. The plug contains all
2 Harness identification code:
sockets and the receptacle contains all pins. This example indicates wire group 325, Wire Gauge*
wire 135 in harness "AG". Wire Color
1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle *Wire gauge is shown in AWG (American Wire Gauge)
2 contain both pins and sockets. but could also be shown in metric denoted with mm

© 2020 Caterpillar. All Rights Reserved. CAT, CATERPILLAR, LET’S DO THE WORK, their respective logos, “Caterpillar Yellow,” the “Power Edge”
and Cat “Modern Hex” trade dress, as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without
permission.

(Dimensions: 34 inches x 24 inches)


UENR2155-01
16 Page,
LONG RANGE RADAR
REAR RADAR R-C1
365-1271 2305010
-BATTERY 1 C234-R5 BK-14
CAN 1 HIGH 2 K900-R26 YL-18
CAN 1 LOW 3 K990-R34 GN-18
+12V 4 C569-R2 YL-14 C234-R6 BK-14 C234-CM6 BK-14
MPIO 1 5 C234-R6 BK-14 C234-R5 BK-14
6
C234-R1 BK-14
CAB
GROUND 200-CM4 BK-14
C569-R2 YL-14 200-CM7 BK-14

R-C3
K900-R26 YL-18 K900-R3 YL-18
1330973
K900-R19 YL-18
A K900-R19 YL-18
CAN 1 TERM RES B
174-3016
B K990-R27 GN-18 CONN 1
C
EBAY CONN CAB CONN
K990-R34 GN-18 K990-R4 GN-18
K990-R27 GN-18 E-C2 CM-C12
3595179 3595180
109-E3 RD-12 130-E1 RD-14 A 130-CM1 RD-14
20A
308-E5 YL-14 B 308-CM55 YL-14 CM-C4
OBJECT DETN BRKR E-C1 C 1552273
6T-3644 3045284 D 130-CM3 RD-14 1 +24V BATTERY IN
1 2 308-FUSE2 YL-12 E 308-CM9 YL-16 2 +24V SWITCHED IN
F 200-CM7 BK-14 3 GROUND
G 4
H C569-CM20 YL-14 5 +12V SWITCHED OUT
J 6
K
24V 12V-CONV
L
340-7161
M
N
P

308-FUSE1 YL-12 130-CM1 RD-14 130-CM2 RD-14


130-CM3 RD-14
MAIN PWR RELAY
165-4026
109-CM29 MUST BE CONNECTED TO THE UNSWITCHED SIDE (109 OR) 200-CM4 BK-14
CONNECT TO THE EXISTING MAIN POWER RELAY 200-CM7 BK-14
CONN 2
CM-C6 CAN 1 TERM RES A
WIRES IN THE FOLLOWING CHASSIS CONN CAB CONN 1330973 174-3016
GROUPS SHALL BE TWISTED: R-C4 CM-C9
308-CM9 YL-16 K900-CM25 YL-18 A
ONE TWIST PER 25 MM. 3595179 3595180
308-CM55 YL-14 308-CM8 YL-16 K990-CM27 GN-18 B
WIRE GROUP WIRE NAME K900-R3 YL-18 A K900-CM26 YL-18 C
CM_TW2 892-CM14 K990-R4 GN-18 B K990-CM28 GN-18
C 892-CM15 BR-16 892-CM14 BR-16
CM_TW2 893-CM12
D 892-CM10 BR-16
CM_TW4 K900-CM17 E
CM_TW4 K990-CM16 F

CM_TW6 892-CM10
G 893-CM11 GN-16 893-CM12 GN-16
C234-R1 BK-14 H C234-CM6 BK-14 893-CM13 GN-16
CM_TW6 893-CM11 J
CM_TW7 892-CM15 C569-R2 YL-14 K C569-CM20 YL-14 C234-CM6 BK-14
L
CM_TW7 893-CM13
M
CM_TW8 K900-CM25 N CMPD DISPLAY
CM_TW8 K990-CM27 P 355-9048
C569-CM20 YL-14 CM-C1
CM_TW9 K900-CM26
1552252 POWER
CM_TW9 K990-CM28
K900-CM17 YL-18 1
R_TW1 K900-R19
T557 MODEL: CONN 3 K900-CM26 YL-18 K900-CM25 YL-18 2
R_TW1 K990-R27 UNPLUG FROM ECAP CONN CV-C1(9W1951)
3
CM-C8 CM-C7 4
R_TW5 K900-R26 PINS D&E AND CONNECT TO CM-C8 1552269 3E3364 K990-CM16 GN-18 5
R_TW5 K990-R34 PIN D 893-CV12
PIN E 892-CV11 892-AG68 BR-16 1 892-CM10 BR-16 K990-CM28 GN-18 K990-CM27 GN-18 6
T_TW1 K900-R3 893-AG69 GN-16 2 893-CM11 GN-16 K900-CM17 YL-18 7 CAN 1 HIGH

T_TW1 K990-R4 TT009 MODEL: K990-CM16 GN-18 8 CAN 1 LOW


UNPLUG FROM CONN TO PAYLOAD CONTROL HARNESS (3E5179 12 PIN DT) 9
PINS 8 & 9 OF U-27 AND CONNECT TO CM-C8 308-CM8 YL-16 10 KEYSWITCH INPUT
PIN 9 892A-BR 130-CM2 RD-14 11 +12V MEMORY OUT
PIN 8 893A-GN 200-CM4 BK-14 12 +24 V BATTERY IN
TT009 MODEL 892-CM15 BR-16
CONNECT TO U-C27 CM-C2
PINS 8&9 1552253 USB
1
T557 MODEL 2
CONNECT TO CV-C1 893-CM13 GN-16 3
PINS D&E 4
5
6
893-CM12 GN-16 7 CDL HIGH
892-CM14 BR-16 8 CDL LOW
9
10
11
12

CMPD CAMERA JUMMPER


319-6827 VIDEO
1 +V CAMERA
REAR CAMERA CABLE C1 REAR CABLE BULKHEAD CAB REAR CAMERA CABLE 2 RTN CAMERA
REAR CAMERA REAR CAMERA CABLE 2 333-8153
251-8248 251-8248 REAR CAMERA 3 CH 4 VIDEO RTN
336-6684 261-3223
VIDEO SIG VIDEO SIG VIDEO SIG 4 CH 3 VIDEO RTN
VIDEO SIG VIDEO SIG
VIDEO RTN VIDEO RTN VIDEO RTN 5 CH 2 VIDEO RTN
VIDEO GND VIDEO RTN
+V CAMERA +V CAMERA +V CAMERA 6 CH 1 VIDEO RTN
+ 12 VDC +V CAMERA
RTN CAMERA RTN CAMERA RTN CAMERA 7 CH 1 VIDEO SIG
FEED GND RTN CAMERA
8 CH 2 VIDEO SIG
9 CH 3 VIDEO SIG
10 CH 4 VIDEO SIG
11
12
(Dimensions: 34 inches x 24 inches)
UENR2155-01

CALLOUT FORMAT IF APPLICABLE


Callout Number Component
(Machine Location from (52) VALVE GP - CONTROL Name
Component Locations Table)
138-1234 Part Number

SYMBOL DESCRIPTION ABBREV COLOR


CIRCUIT CONNECTED RD RED

WH WHITE
CIRCUIT NOT CONNECTED
OR ORANGE
ELECTRICAL CONNECTION TO
MACHINE STRUCTURE
YL YELLOW
INTERNAL ELECTRICAL CONNECTION
TO SURFACE OF COMPONENT PK PINK

CONNECTOR BK BLACK

CIRCUIT DESCRIPTION TABLE GY GRAY


H# CIRCUIT GROUPING DESIGNATION
Model: 793D PROTO OBSTACLE DETECTION.DGM
PU PURPLE
CIRCUIT # COLOR DESCRIPTION ATCH WIRE, CABLE, COMPONENT
BR BROWN
308 YL KEY SWITCH INPUT
SPLICE
109 RD MAIN POWER RELAY GN GREEN
BLADE, SPADE, RING OR SCREW
130 GN POWER OBSTACLE DETECTION MISC. REF. VIDEO CABLE PART NUMBERS TERMINAL BU BLUE

200 BK GROUND
C234 BK SENSOR RETURN PART NUMBER DESCRIPTION
16 Page,

308 YL KEY SWITCH INPUT 283-0657 3 METER VIDEO CABLE


T557 AND TT009 (988G-ALL CONFIGS)
C569 YL 12V OUTPUT 274-4477 5 METER VIDEO CABLE
892 BR CAT DATA LINK NEGATIVE 283-0658 7.5 METER VIDEO CABLE IDENT PART NO. CHG LOC NOTE DESCRIPTION Do not operate or work on this product unless you have
893 GN CAT DATA LINK POSITIVE 283-0659 9 METER VIDEO CABLE R 363-7102 01 E-8 CHASSIS read and understood the instruction and warnings in the
K900 YL CAN 2 DATA LINK POSITIVE 274-4478 11 METER VIDEO CABLE E 360-1710 02 E-6 EBAY relevant Operation and Maintenance Manuals and
274-4479 16 METER VIDEO CABLE
relevant service literature. Failure to follow the instruc-
K990 GN CAN 2 DATA LINK NEGATIVE CM 360-0195 03 D-4 MAIN CAB
tions or heed the warnings could result in injury or
WIRE GROUP COLOR DESCRIPTIONS death. Proper care is your responsibility.
GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
VOLTAGE CONVERTER OUTPUT CIRCUIT
CAT DATA LINK THIS SCHEMATIC IS FOR THE 988G WHEEL LOADER CAT® DETECT OBJECT DETECTION
CAN DATA LINK
ELECTRICAL SYSTEM
OTHER COLOR DESCRIPTIONS MEDIA NUMBER: UENR2155-01
HIGHWAYS
SCHEMATIC PART NUMBER: 359-4565, CHANGE: 01, VERSION: -
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

You might also like