This document is a quiz from a university electronics course. It contains a single question with multiple parts about analyzing the noise and gain of a low noise amplifier circuit. The circuit schematic shows a noise cancelling single-ended to differential amplifier. Students are asked to calculate the small signal output resistance, voltage gain, input impedance, noise from one transistor, and noise cancelling condition for the circuit.
This document is a quiz from a university electronics course. It contains a single question with multiple parts about analyzing the noise and gain of a low noise amplifier circuit. The circuit schematic shows a noise cancelling single-ended to differential amplifier. Students are asked to calculate the small signal output resistance, voltage gain, input impedance, noise from one transistor, and noise cancelling condition for the circuit.
This document is a quiz from a university electronics course. It contains a single question with multiple parts about analyzing the noise and gain of a low noise amplifier circuit. The circuit schematic shows a noise cancelling single-ended to differential amplifier. Students are asked to calculate the small signal output resistance, voltage gain, input impedance, noise from one transistor, and noise cancelling condition for the circuit.
ECE Department Duration: 30 min – Pages 1 Quiz: 3 – 10 Marks Question 1 (10 Marks) Unless stated otherwise, assume finite output resistance and neglect the bulk effect for all transistors. Assume 0.5μm CMOS process with the following parameters (VDD = 3V): NMOS: Vth = 0.7V, μnCox = 135μA/V2, λno = 0.1 V-1 𝛾𝑛=0 PMOS: Vth = -0.8V, μpCox = 40μA/V2, λpo = 0.2 V-1 𝛾𝑝=0 Noise parameters: 𝛾 = 2/3, 𝐾𝑓 = 10−25 𝑉2𝐹 1- The schematic below1 shows a noise cancelling low noise amplifier (LNA) that also performs single-ended to differential conversion [the output defined here as the difference between node Y and N, Vout= (VY-VN)]. For both cases 𝝀 ≠ 𝟎 and 𝝀 = 𝟎, answer the following: a) Find the small signal Rout at Node Y.
b) Find the small signal gain Av (Vout/Vin).
c) Find the small signal input impedance shown in the figure (Zi/p).
For 𝝀 = 𝟎 only, answer the following:
d) Find expression for the output noise of M1.
e) Find the noise cancelling condition to fully cancel the portion of M1 noise at the output.