Professional Documents
Culture Documents
NORTHERN RLY
FEROZPUR DIVISION-
ENGINEERING
Divisional Railway Manager
Office, Near Railway Officers
Club
Firozpur, 152001
Punjab, India
Ref: 1. Tender No. 124-2021-22-ADEN-II-FZR closing date 09-02-2022 15:00 for Crossing
of 800 MM dia RCC sewer Pipe Line Passing through 1200 mm MS encasing pipe &
1400 mm dia Ms casing pipe under the Railway Track near level crossing no C-12 at
Km 18/1-2 on JUC_NRO section under ADEN-II/FZR
2. Your bid ID 13432244 dated 09/02/2022 14:19
The Competent Authority has accepted your offered rates in connection with the subject work. The
total cost of the work at the accepted rates works out to Rs. 6829437.72 (Rupees Sixty-Eight Lakh
Twenty-Nine Thousand Four Hundred And Thirty-Seven Rupees And Seventy-Two Paise Only)
A sum of Rs.132200 deposited as Earnest Money vide IREPS reference ID PE660514534583 has been
retained towards initial Security Money for due and faithful fulfillment of the contract, and the balance
Security Money will be recovered from the progressive bills @ 6 % of the bill amount till it reaches 5 % of
the contract value in terms of clause 16(1) of GCC July 2020.
You are requested to submit Performance Guarantee in the form as given in Clause 16(4) of GCC July
2020 equivalent to 3 % of the contract value amounting to Rs. 204883.13 (Rupees Two Lakh Four
Thousand Eight Hundred And Eighty-Three Rupees And Thirteen Paise Only) within 21 days from the
date of issue of Letter of Acceptance, valid up to stipulated date of completion plus 60 days so that
contract agreement can be executed. However, a penal interest of 12% per annum shall be charged for the
delay beyond 21(Twenty one) days, i.e. from 22nd day after the date of issue of LOA. Further, if the 60th
day happens to be a declared holiday in the concerned office of the Railway, submission of PG can be
accepted on the next working day.
The entire work shall be completed within 4 month from the date of issue of Letter of Acceptance.
Condition 1 : The overall cost of this work is below by more than 10.00% hence the rates of all items of
this work may not be used for future estimation & comparison in isolation till completion of this work.
Condition 2: The quantities of all USSOR Chapters & NS-6 are more than 10.00% below so these items
should be utilized as maximum as possible and should not be reduced without prior approval of tender
accepting authority.
All Other terms and conditions, as stipulated in the tender documents shall be applicable.
DEVENDRA KUMAR
DENTrack
Digitally Signed
View Signature Details
Item Item Desc Item Item Qty Unit Rate Escl. Advt.Value Bid Rate/ Bid Amount (Rs)
Sno. Code Qty Unit (Rs) (%) (Rs) Unit Rate
%
Schedule A-USSOR ITEMS-2010 (Item Directory - NR-HQ-USSOR-2010-1-Ver-4) 3093898.13 10.00 2784508.32
Below
1 Ch-1 Earth work View Details 8.16 43400.07
2 Chapter-02 carriage of material View Details 1.55 59612.73
3 Chapter-03 Plain concrete View Details 22.00 644100.94
4 Chapter-04 RCC work View Details 22.30 1071741.87
5 Chapter-05 Brick Work View Details 32.65 237155.52
6 Chapter-08 steel and aluminium work View Details 22.27 363178.58
7 Chapter-09 Flooring paving and Dado View Details 9.01 178111.98
8 Chapter-10 Roofs and ceiling View Details 10.21 3461.50
9 Chapter-11 Finishing and Masonary View Details 7.51 93976.53
Chapter-12 Painting polishing and
10 View Details 10.24 26236.68
varnishing
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022
Page 2 of 6
Item Breakup
Schedule A-USSOR ITEMS-2010
Extra over item 011010 for excavation in foundations for buildings and
bridges to cover dressing to neat dimension and plumbing sides etc.
2 012010 cum 200 8.70 1740.00
Note : Dressing under this item is payable for the total quantity of
excavation in foundation and not partly
Extra for watering and ramming earth in foundation and floors in 15cm
3 012030 layers. Note : This item is payable where ramming is not included in cum 80 15.40 1232.00
the original rate for earthwork in filling.
Total 40125.80
Total 58702.84
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022
Page 3 of 6
Total 527951.59
All work upto plinth level, including raft foundation of washable aprons,
1 041011 cum 35 2422.38 84783.30
HS tank, pile cap, footings of FOB, and Platform shelter etc.
2 041012 All work in buildings above plinth level upto floor two level. cum 25 2645.23 66130.75
5 042015 Columns, pillars, , posts and struts Sqm 150 240.50 36075.00
Providing, hoisting and fixing in position upto floor two level M20
Grade precast RCC work including setting in cement mortar 1:3 (1
cement : 3 coarse sand) and finishing smooth with 6mm thick cement
plaster 1:3 (1 cement : 3 fine sand) on exposed surfaces complete
including cost of centering, shuttering, finishing, Admixtures in
recommended proportion (as per IS:9103) to accelerate, retard setting
of concrete, improve workability without impairing strength and
durability, excluding cost of cement and steel reinforcement, as per
approved plan & direction of Engineer incharge.
Total 876322.05
1 051015 Cement mortar 1:6 (1 cement : 6 fine sand) cum 80 2143.06 171444.80
Extra over item 051010 & 051020 for brick work in superstructure
2 051040 cum 55 133.42 7338.10
beyond plinth level upto floor two level :
Total 178782.90
Total 297030.00
1 092012 40mm thick with 20mm nominal size stone aggregate Sqm 150 120.99 18148.50
2 098023 120mm thick blocks of M40 grade for heavy traffic Sqm 150 968.28 145242.00
Total 163390.50
Providing and fixing on wall face unplasticised - PVC moulded bend and
shoe for unplasticised-Rigid PVC rain water pipes conforming to
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022
Page 4 of 6
Total 3140.82
15mm cement plaster on rough side of single or half brick wall finished
a floating coat of neat cement of mix -
Total 87411.90
2 121051 Two or more coats on new work Sqm 100 40.81 4081.00
Total 23799.60
Providing and fixing G.I. pipes complete with G.I. fittings and clamps,
including cutting and making good the walls etc. Internal work -
Exposed on wall
Providing and fixing medium grade G.I. pipes complete with G.I.
fittings and clamps, including cutting and making good the wall etc.
Concealed pipe including painting with anti corrosive bitumestic paint,
cutting chase and making good the wall
Providing and fixing PTMT bib cock of approved quality and colour
5 134011 15mm nominal bore, 86mm long. Weighing not less than 88 gms Each 1 166.16 166.16
Providing and fixing PTMT stop cock of approved quality and colour
6 134021 15mm nominal bore, 86mm long. Weighing not less than 88 gms Each 1 166.16 166.16
Providing and fixing PTMT angle stop cock 15mm nominal bore.
7 134070 Each 2 218.43 436.86
Weighing not less than 85 gms
Providing and fixing G.I. Union in G.I. pipe including cutting and
threading the pipe and making long screws etc. complete (new work)
Total 21450.64
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022
Page 5 of 6
Total 42532.86
Providing and fixing water closet squatting pan (Indian type W.C. pan)
with 100mm sand cast iron P or S trap, 10litre low level white P.V.C.
flushing cistern with manually controlled device (handle lever)
conforming to IS : 7231, with all fittings and fixtures complete
including cutting and making good the walls and floors wherever
required
Providing and fixing white, vitreous china wash basin, including making
all connections but excluding the cost of fittings
2 151281 Flat back wash basin of size 630x450mm Each 1 817.49 817.49
Providing and fixing PTMT liquid soap container 109mm wide, 125mm
high and 112mm distance from wall of standard shape with bracket of
4 153300 Each 1 185.84 185.84
the same materials/ with snap fittings of approved quality colour and
make, weighing not less than 105gms
Providing and fixing PTMT shelf 440mm long, 124mm width and 36mm
5 153330 height of approved quality, colour and make weighing not less than Each 1 501.91 501.91
300gms
Grating 100 mm nominal dia. and 12 mm. high domed shape having
7 153471 Each 1 81.70 81.70
wt. not less than 25 gms
Providing and fixing 110mm dia PVC soil, waste and vent pipes
9 154010 Metre 10 205.50 2055.00
including jointing and cost of spun yarn and sand etc. complete
Providing and fixing 110 mm PVC bend of the required degree with
access door inclusive of 3mm thick bitumastic felt washer, bolts and
10 154110 Each 3 89.16 267.48
nuts, complete, including jointing and cost of spun yarn and sand etc.
complete
Providing and fixing 110mm dia PVC terminal guard including jointing
11 154120 Each 1 195.13 195.13
and cost of spun yarn and sand etc, complete
Total 10242.14
4 191144 Grain size analysis including Hydrometer analysis Each 1 1161.50 1161.50
Total 13938.00
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022
Page 6 of 6
4cm thick bitumastic sheet with hot bitumen of approved quality using
stone chippings (60% 12.5mm nominal size and 40% 10mm nominal
size) 2.60cum and coarse sand 2.60cum of road surface and with
478kg bitumen per 100sqm of road surface over a tack coat including
consolidation with road roller of 8 to 10tonne etc. complete (tack coat
to be paid separately)
With paving bitumen 80/ 100 heated and then mixed with solvent at
3 234021 Sqm 500 386.69 193345.00
the rate of 70grams per kg. of asphalt
Total 263423.00
Item - 1 NS ITEMS
NS-4) P & F pipe line indicator boards (retro reflective type) including
making foundation complete in all respects as directed by Engineer
4 4 incharge. Nothing extra will be paid on any acount. The payment of Each 4 4607.13 18428.52
cement will be paid seperately under SOR item as per actual
consumption of cement as per std. specifications.
NS-5) Providing and seal on 1200 & 1400 mm dia M.S. pipe of 20mm
5 5 thick 50 mm dia G.I. vent pipe with screen complete as directed by Each 2 18782.25 37564.50
Engineer Incharge.
Total 3517329.91
https://ireps.gov.in/epsn/works/tds/publishLOAWorksLetter.do?Action=ViewPublish... 26-03-2022