You are on page 1of 2

BUILDING TECHNOLOGY

8. A filler product used to fill gap between tiles?


1. A paint defect that is identified by crusty white salt
a. crazing
deposits that bubble through the paint film from a
b. camber
masonry structure?
c. grout
a. peeling
d. form
b. blistering/bubbling
9. Mix that flows sluggishly without segregating & is
c. chalking
readily molded?
d. efflorescence
a. wet mix
2. Applying of paint to a damp or wet surface,
b. slump
applying paint to a dirty orimcompatibly finished
c. plastic mix
surfaced?
d. dry mix
a. peeling
10. Measure of the consistency and workabilty of a
b. blistering/bubbling
freshly mixed concrete?
c. chalking
a. wet mix
d. efflorescence
b. slump
3. Caused by either moisture or poor adhesion, paint
c. plastic mix
peeling and separating from an earlier paint layer?
d. dry mix
a. peeling
11. Mix containing little water or too much
b. blistering/bubbling
aggregate?
c. chalking
a. wet mix
d. efflorescence
b. slump
4. Most common frame material used for
c. plastic mix
warehouses?
d. dry mix
a. steel
12. A hardener mixture mixed with dust to fill-up
b. wood
gaps in marble and wall finishes?
c. concrete
a. Portland cement
d. cement
b. polymer
5. It is a binder for concrete?
c. cement
a. steel
d. hydraulic cement
b. wood
13. A mixture of amorphous silica that reacts to
c. concrete
water?
d. cement
a. Portland cement
6. Also known as pattern cracking, it is characterized
b. polymer
by the appearance of hairline crcks in concrete and
c. cement
glazed materials. In concrete, it is the result of
d. hydraulic cement
surface shrinkage occurring at a faster rate than
14. What do you call the process of excavating,
shrinkage below th surface.
moving the excvated material, and using it t the
a. crazing
nearby location whereby the amount of axcavated
b. camber
material roughly matches the amount of filling
c. grout
material?
d. form
a. cut and fill
7. It is receptacle in which concrete is placed, so that
b. segregation
it will have th desired shape or outline when
c. balloon framing
hardened. Once the concrete develos adequate
d. assembly
strength, it is removed. It is usually made of
15. Separation of coarse aggregate from the mortar
materials like plywood or steel?
or of water from the other ingredients.
a. crazing
a. cut and fill
b. camber
b. segregation
c. grout
c. balloon framing
d. form
d. assembly

1|BUILDIN G TECHN OLOGY


16. What do you call the recess at the bottom of a 24. Rebar diameter commonly used for both
base cabinet that allows your feet to get close to the horizontal and vertical reinforcement for CHB walls?
counter top without losing your balance? a. 8 mm
a. nosing b. 10 mm
b. finger joint c. 12 mm
c. caulking d. 13 mm
d. toe kick
25. Vernacular term for "laying of CHB"
17. The projecting part of a stair tread extending a. asintada
beyond the riser. b. hulog
a. nosing c. plantilya
b. finger joint d. palitada
c. caulking
d. toe kick 26. Vernacular term for "vertical alignment"
a. asintada
18. Frame that carries a door? b. hulog
a. rafter c. plantilya
b. gutter d. palitada
c. rivets
d. door jamb 27. The edges of the roof which overhang the face of
a wall and normally project beyond the side of a
19. Material to fasten GI? building. It forms an overhang to throw water clear
a. rafter of the walls?
b. gutter a. eaves/alero
c. rivets b. studs
d. door jamb c. knot
d. ground breaking
20. It is the metal used for collecting water and is
attached to the fascia board? 28. Wall framing?
a. rafter a. eaves/alero
b. gutter b. studs
c. rivets c. knot
d. door jamb d. ground breaking

21. Proper sequence in mixing concrete? 29. The base of a woody branch enclosed by a
a. cement, sand, gravel, water subsequent growth of wood in the stem from which
b. cement, sand, water, gravel it rises.
c. cement, gravel, sand, water a. eaves/alero
d. cement, water, sand, gravel b. studs
c. knot
22. A roof having sloping ends ana sides meeting at d. ground breaking
an inclined projecting angle?
a. gambrel 30. What ceremony is undertaken before
b. gable commencement of a project?
c. hip a. eaves/alero
d. mansard b. studs
c. knot
23. A roof having on each side a steeper lower part d. ground breaking
and a shallower upper part.
a. gambrel
b. gable
c. hip
d. mansard

2|BUILDIN G TECHN OLOGY

You might also like