Professional Documents
Culture Documents
LAPANGAN JATIASRI
No. Dok. : JAS-EPC-SP-DYN-20-R1-PR-004
FAT PROCEDURE
Rev. : A
Halaman : Hal 1 dari 10
Ini yang di FAT jenis pompa apa?
LOKASI : SP JATIASRI
Issued for
B 30 Oct 2023 Approvak TN TN IR AK PUR
28 AGUSTUS Issued For
A 2023 Approval TN TN IR AK PUR
DIPERIKSA DISETUJUI DIPERIKSA DISETUJUI
KONSORSIUM
REV. TANGGAL DESKRIPSI DISIAPKAN PT. WAHANAKARSA SWANDIRI – PT. ALDABERTA
DYNAPRO PUMPS ASIA INDONESIA
FAT PROCEDURE JAS-EPC-SP-DYN-20-R1-PR-004
PT. PERTAMINA EP / REGIONAL 2 – FUNGSI PROJECT ZONA 7 REV.A
PEMBANGUNAN STASIUN PENGUMPUL JATIASRI Hal 2 dari 10
TABEL REVISI
DAFTAR ISI
Nama...
yang di FAT centrifugal Pump atau Fire Pump?
FAT PROCEDURE FOR FUEL TANK AND VALVE ACCESSORIES
1. Tank is filled with water to the brim, using PDAM Water up to nozzle level limit in the tank.
2. After the tank is full of water, leak test is carried out on the discharge welded joint, drain, and
the entire tank shell and tank body using a lime marker to make it easier to find out any
indications of leakage.
3. After the leak test, the tank is held for 1 x 24 hours, and 100% visual test is carried out.
4. After holding 1x 24 hours, there is no leakage and testing is acceptable, then the water is
drained and dried, then the inside tank shall be coated with diesel oil so as not to expand.
5. Review / approval of report documents must be completed and copies submitted to all parties
involved.
1. Prepare the Air Release Valve and Vlok Ring for connection to the testing tool.
2. Connect the Vlok Ring and Male Connector using seal tape.
3. Position it standing/vertically to detect leaks.
4. Give pressure and holding time according to the their class rating in the valve data sheet.
5. Check visually for leaks throughout the valve.