Professional Documents
Culture Documents
(Regulations 2021)
1. Carry out deflection test on simply supported beam and compare results theoretically. (100)
Note:
4. Determine the Euler load for the given pinned-pinned column with eccentric loading and compare
6. Conduct unsymmetrical bending test on a Z section beam and determine the principal planes for the
Z section. Verify the results graphically. (100)
Page 1 of 3
7. Conduct an experiment to determine the material fringe value for the given beam section made of
photo elastic material by subjecting to flexural loads. (100)
8. Conduct an experiment to determine the Natural frequencies (free vibration) of the given cantilever
beam. (100)
9. Conduct an experiment to locate the Shear centre for the given channel section. (100)
10. Conduct an experiment to determine the stresses in the flange and web portion of the given Wagner
beam subjected to a shear load at the free end. Determine the angle of diagonal tension (Alpha).
(100)
11. Experimentally find deflection of the cantilever beam. Compare experimentally observed deflection
with solution obtained from strength of material. (100)
12. Conduct an experiment to determine the maximum and minimum principal stresses for the given
shaft subjecting to combined bending and Torsional load. (100)
Note:
13. Conduct an experiment to determine Elastic constants for a given Glass/Epoxy composite Flexural
Specimen. (100)
14.
Fabricate the composite laminate for the given dimension (200 mm x 150mm). Write the
Page 2 of 3
advantages of composite materials. (100)
15. Conduct an experiment to determine Elastic constants for a Glass / Epoxy composite Tensile
Specimen. (100)
Note:
16. Conduct an experiment to determine the material fringe value for the given circular section made of
photo elastic material by subjecting to diametrical compression. (100)
17. Conduct an experiment to determine the Natural frequencies (Forced vibration) of the given
cantilever beam. (100)
18. Conduct an experiment to locate the Shear centre for the given open channel section subjected to a
vertical load of 2kg and 3 kg. Give reasons for the variation if any. Draw the shear flow pattern for
the given section. (100)
19. Fabricate the glass/epoxy composite laminate (150 mm x 150 mm). (100)
Note:
20. Experimentally find Euler load (P ) for the given pinned-pinned column (Aluminium bar) using
cri
Page 3 of 3