Professional Documents
Culture Documents
Base Metal Part I (Material Spec., type or grade): Base Metal Part II (Material Spec., type or grade):
Group I and II of table 3.1 – AWS D1.1 Group I and II of table 3.1 – AWS D1.1
T ≤ 1/2 3/16
drawing
T ≤ 3/4 ¼
T ≤1-1/2 5/16
T≤2-1/4 3/8
Joint Detail/Sketch:
RF ≥
G =
E =
T ≥ 8mm
Joint Design Used (Design information for Prequalified WPS as shown in Sketch):
Root Opening G: mm (in) 0 Root Dace RF:- Groove Angle:- Radius (J-U): n/a
Identification : SMAW
Electrical Characteristics: Shielding:
Current Type Polarity: DCEP
Transfer Mode:
Welding Procedure
Filler Wire Travel
Current
Weld Pass Filler Metal Metal Curren Feed Speed Remarks or
Process Type & Volts
Layer(s) No. Classification Diameter t Amps Speed (in/min Heat Input
Polarity
mm(in) (in/min) )
1 1 SMAW E6018- 100 A DCEP - 36 V Fill Pass
A5.5/
A5.5M
1 to 2 2 to
3
2 to n 3 to
n
Technique:
Stringer or Weave Bead:
Initial/Interpass Cleaning:
Number Of Electrodes:
Electrode Spacing:
Heat Treatment:
Preheat Temp: Interpass Temp:
Postweld Heat Treatment: Time: n/a
Additional Notes:
Name: Name:
Title: Title:
Date Date: