Professional Documents
Culture Documents
5
Determination of Center of Pressure
And Hydro-static Force on Plane surface
Objective: -
To determine the position of the line of action of the thrust and to compare
the position determined by experiment with the theoretical position.
Apparatus: -
Hydrostatic pressure apparatus, ruler, weights, water, scale cylinder.
Theory: -
M g * L = F * h"
Where,
M : is the mass on the weight hang,
g : is the acceleration due to gravity,
L : is the length of the balance arm,
F : is the hydrostatic force , and
h” : is the distance between the pivot and the center of pressure.
Procedure: -
1. Check the bench is leveled properly with the use of spirit level.
2. Add a small mass (typically 50g) to the weight hanger.
3. Get tap water using steel vessel and fill up the flotation tank.
4. Fill the floatation tank with water initially until the balance arm rises.
Avoid wetting the balance arm or the quadrant above the water level in the
tank.
5. Continue to add water until the balance arm is horizontal, checking this by
aligning the flat of the balance arm with the central mark on the level
indicator.
6. When the arm is horizontal read the depth of immersion from the scale on
the face of the quadrant.
7. Repeat the above procedure for different load increments by adding
further weights to the weight hanger.
8. Continue until the water level reaches the top of the upper scale on the
quadrant face.
9. Repeat the procedure in reverse, by progressively removing the weights.
Calculations and Results Procedure: -
All readings must be recorded as follows :
Constants
Height of End Face: D =10 (cm)
Width of the End Face B =7.5 (cm)
Length of Arm L =25 (cm)
Height of Pivot H =20 (cm)
Discussion: -
What are the reasons for the difference between h"th and h"act .
Ans: -
the differences due to may be the possibility of a human error in reading when
the balance bridge arm flat and the balance may be inaccurate in measuring
the masses or the possibility that the height value is not accurate if the ruler
of measurement is inaccurate