Professional Documents
Culture Documents
Voltage Transformer
Voltage Transformer
..\WorkInstructions\24.pdf
For Mechanical Check/Visual Inspection and Electrical Tests Use C.L. of W.I.24
Instrument :
Make :
Model No. / Sl. No. :
Primary-Secondary-1
Primary – Secondary 2
Secondary1 – Earth
Secondary 2 – Earth
Secondary 1 – Secondary 2
Instrument :
Make :
NOTE: 1.
Rc = Calculated value at 75 C
Rm = Measurement value which contained a measurement cable.
NOTE: 2
Calculated 75 C Rc = (Rm-Rx) x (234.5+75)
(234.5+Ta)
NOTE: 3
3. Ratio Test
Voltage Applied to Primary: Volt (Full Tap) & Volt (Mid Tap)
Measured
Theoretical Ratio
Phase Tap Secondary Measured Ratio % Error
Voltage
Core-1 Core-2 Core-1 Core-2 Core-1 Core-2 Core-1 Core-2
Full Tap
A
Mid Tap
Full Tap
B
Mid Tap
Full Tap
C
Mid Tap
4. POLARITY TEST :
Instrument :
Tick here if found okay
Polarity checked
Phase Core
& found okay
A 1
2
B 1
2
C 1
2
6.PHASE TEST:
7. Burden Test :
INSTRUMENT :
Multimeter :
Make :
Test Results:
1
B
2
1
C
2
Make :
Procedure
a) Remove the connections in primary side of voltage transformers in all the three
phases to ensure that the primary induced voltage is not fed to the switchgear bus or the other equipments.
b) Apply the voltage to secondary terminals of one of the core of the PT.
Gradually increase the voltage up to 1 volt and check the corresponding
Voltage developed in the same secondary terminal of the core.
1a2-1n 2a2-2n